User manual AIRTRONIC D4 OKUS

[. . . ] AIRTRONIC / AIRTRONIC M Technical description, installation, operation and maintenance instructions. AIRTRONIC AIRTRONIC D2, 12 V AIRTRONIC D2, 24 V Complete package AIRTRONIC D2, 12 V AIRTRONIC D2, 24 V Order no. 25 2069 05 00 00 25 2070 05 00 00 25 2115 05 00 00 25 2116 05 00 00 AIRTRONIC M AIRTRONIC D3, 12 V AIRTRONIC B4, 12 V AIRTRONIC D4, 12 V AIRTRONIC D4, 24 V AIRTRONIC D4 Plus, 12 V AIRTRONIC D4 Plus, 24 V Order no. 25 2317 05 00 00 20 1812 05 00 00 25 2113 05 00 00 25 2114 05 00 00 25 2484 05 00 00 25 2498 05 00 00 Air heater for diesel and petrol operating independently of the engine. 25 2069 90 99 52 04. 2009 1 Introduction Contents Chapter Title Contents · · · · · · · Page 1 Introduction Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Concept of this manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ] The , , Plus" installation kit includes a combustion air intake silencer with a flexible connection hose (inner diameter 25 mm). Fasten the flexible connection hose to the heater with a pipe clip and fasten the combustion air intake silencer with hose clips or cable ties at suitable points. Fit an end sleeve after completing the installation. Safety instructions for the combustion air system!· The combustion air opening must be free at all times. · Position the combustion air intake to be sure that exhaust fumes cannot be sucked in with the combustion air. · Do not arrange the combustion air intake to pointing against the wind blast. · The combustion air intake must not get clogged with dirt and snow. · Install the combustion air intake system sloping slightly downwards. Ø 5 mm at the lowest point to drain off condensation. · For AIRTRONIC and AIRTRONIC M heaters a combustion air intake silencer can be fitted instead of the combustion air hose to reduce the noise level. The order number is stated in the Accessories Catalogue. · Comply with the regulations and safety instructions for this chapter on page 4 ­ 7. min. 2 m 1 2 Combustion air hose, di = 25 mm Combustion air silencer, ­ Included in the "Plus" installation kit 3 Exhaust pipe, de = 24 mm 4 Exhaust silencer 5 Intake / outlet opening ­ protect from wind, snow, dirt and water. 6 End sleeve, combustion air 7 End sleeve, exhaust 8 Combustion air connection 9 Exhaust connection 10 End sleeve, combustion air 11 Hose clip 12 Exhaust hose clip 23 3 Installation Fuel supply Mounting the dosing pump, routing the fuel pipes and mounting the fuel tank The following safety instructions must be observed when mounting the dosing pump, routing the fuel pipes and mounting the fuel tank. Deviations from the instructions stated here are not allowed. Failure to comply can result in malfunctions. · Route the fuel pipes so that any distortion of the vehicle, engine movements etc. cannot have any lasting effect on the service life. · Parts carrying fuel must be protected from interfering heat. · Never route or fasten the fuel pipes to the heater or vehicle exhaust system. At crossings, always ensure adequate heat clearance, if necessary attach heat deflection plates or protective hose (for Order No. [. . . ] 31 Safety check (before starting) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29 Scope of supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 ­ 11 Storage temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 ­ 14 Statutory regulations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]