User manual APRILIA RSV MILLE R 2002

[. . . ] - Noale (VE) First edition: august 2002 Reprint: Produced and printed by: DECA s. n. c. Via Risorgimento, 23/1 - Lugo (RA) - Italia Tel. +39 - 0545 35235 Fax +39 - 0545 32844 E-mail: deca@decaweb. it www. decaweb. it On behalf of: aprilia s. p. a. Galilei, 1 - 30033 Noale (VE) - Italia Tel. [. . . ] SURNAME: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . NAME: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ADDRESS: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . TELEPHONE NO. : . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . POSITIONING THE VEHICLE ON THE STAND SIDE STAND To place the vehicle on the side stand while seated astride the vehicle, see p. If any manoeuvre (for example, moving the vehicle) required the lifting of the stand, to place the vehicle on the stand again, proceed as follows: Press the side stand with your right foot and extend it completely (3). Incline the vehicle until the stand rests on the ground. Steer the handlebar completely left- wards. Make sure that the parking surface is free from obstacles, firm and flat. Choose a suitable parking area, see p. NOTE 57 (PARKING). Grasp the left grip (1) and rest your right Very often stolen vehicles are identified thanks to the data written in the use/maintenance manual. hand on the rear upper part of the vehicle (2). 58 use and maintenance RSV mille !- RSV mille R ! MAINTENANCE Risk of fire. Keep fuel and other flammable substances away from the electrical components. Before beginning any service operations or inspection of the vehicle, switch off the engine and remove the key, wait until the engine and the exhaust system have cooled down and, if possible, lift the vehicles with the proper equipment onto firm and flat ground. Before proceeding, make sure that the room in which you are working is properly ventilated. Keep away from the red-hot parts of the engine and of the exhaust system, in order to avoid burns. Do not hold any mechanical piece or other parts of the vehicle with your mouth: the components are not edible and some of them are noxious or even toxic. Routine maintenance operations can usually be carried out by the user, but sometimes specific tools and specific technical skills may be required. In case periodic maintenance operations, assistance or technical advice are needed, contact an aprilia Official Dealer, who will ensure you prompt and accurate servicing. Ask your aprilia Official Dealer to test the vehicle on the road after a repair or periodic maintenance operation. In any case, personally carry out the "Preliminary checking operations" after any maintenance operation, see p. 49 (PRELIMINARY CHECKING OPERATIONS). NOTE This vehicle is set so that any anomaly can be detected in real time and stored by the electronic unit. Whenever the ignition switch is brought to position "B", the writing "efi" (1) appears on the right side of the multifunction display for approximately three seconds. If not expressly indicated otherwise, for the reassembly of the units repeat the disassembly operations in reverse order. In case any maintenance operation should be required, it is advisable to use latex gloves. If the writing "efi" (1) is displayed during the normal operation of the engine, this means that the electronic unit has detected an anomaly. In many cases, the engine keeps running with reduced performance levels; immediately contact an aprilia Official Dealer. After the first 1000 km and successively every 7500 km, the word "SERVICE" (2) appears on the right display. In this case contact an aprilia Official Dealer, who will carry out the operations indicated in the regular service intervals chart, see p. To make the writing "SERVICE" disappear, press the "LAP" push button (3) and then the push button S (4) and keep them pressed for about five seconds. use and maintenance RSV mille !- RSV mille R ! 59 REGULAR SERVICE INTERVALS CHART OPERATIONS TO BE CARRIED OUT BY THE aprilia Official Dealer (WHICH CAN BE CARRIED OUT EVEN BY THE USER). = check and clean, adjust, lubricate or change, if necessary; " = clean; # = change; $ = adjust. Component Spark plugs (*) Air cleaner Engine oil filter (*) Engine oil filter (on oil tank) Fork Light operation/direction Light system Safety switches Clutch fluid Brake fluid Coolant Engine oil Tyres Tyre pressure (**) Engine idling rpm Engine oil pressure warning light LED Drive chain tension and lubrication Brake pad wear After running-in (1000 km) Every 7500 km or 12 months ! [. . . ] 230°C, high protection against corrosion, good resistance to water and oxidation. Protection of the battery poles: neutral grease or vaseline. Spray grease for chains (recommended): 0 0 0 CHAIN SPRAY or CHAIN LUBE. @ aWARNING Brake fluid (recommended): 0 F. F. , DOT 5 (DOT 4 compatible) or Use new brake fluid only. BRAKE 5. 1, DOT 5 (compatible DOT 4). aWARNING BRAKE 5. 1, DOT 5 (compatible DOT 4). Clutch fluid (recommended): 0 F. F. , DOT 5 (compatible with DOT 4) or 0 ECOBLU ­40°C or Use new clutch fluid only. aWARNING COOL. OILN-AUS Use only antifreeze and anticorrosive without nitrite, ensuring protection at -35°C at least. [. . . ]