User manual APRILIA RSV MILLE TUONO 2003

[. . . ] - Noale (VE) FOREWORD INTRODUCTION This manual is divided into sections, chapters and paragraphs, by subject. The procedures described are laid out in single operation, and each operation is indicated by a . The numbered parts shown in the figures are identified in the text with the number in parentheses or with the symbol representing them. Example (the following text is generic and does not refer to this specific vehicle): section MAIN INDEPENDENT CONTROLS NOTE This manual is an important and integral part of your vehicle. [. . . ] Do not attempt to restart the engine until the throttle has been repaired and works perfectly. Failure to obey this warning can lead to a runaway with seriously injuries or even death. - RSV mille R TUONO NOTE This vehicle is set so that any anomaly stored by the electronic control After the first 625 mi (1000 km) and successively every 4687 mi (7500 km), the word "SERVICE" (2) appears on the right display. In this case contact your local aprilia use and maintenance RSV mille TUONO 71 Your vehicle is equipped with a double cable throttle. One cable opens the throttle when you rotate the throttle grip toward you; the other closes the throttle when you rotate the grip away from you. It is essential, when you release the throttle grip, that it automatically return to the idle position. This double cable arrangement enhances safety by providing for positive closing of the throttle. In the event of a throttle sticking emergency, always kill the engine using the engine stop switch located near the throttle grip on the right handlebar. Never use your vehicle if the throttle does not automatically fully return to the idle position when the throttle grip is released. Contact your local aprilia Dealer for repairs. Failure to heed this warning can lead to a serious accident and subsequent injury or even death. If any fastener is loose, the rider may lose control of the vehicle and risk an accident. Both situations may cause serious injuries or even death. 72 use and maintenance RSV mille TUONO - RSV mille R TUONO PRELIMINARY CHECKING OPERATIONS Component Front and rear disc brakes Accelerator Engine oil Wheel/tires Brake levers Clutch Steering Side stand Fastening elements Drive chain Fuel tank Coolant Engine stop switch ) ( Lights, warning lights, horn, rear stoplight switch and electric devices Check Check the functioning, the idle stroke of the control levers, the fluid level and make sure there are no leaks. If necessary, top up the fluid reservoir. Make sure that it works smoothly and that it is possible to open and close it completely, in all steering positions. If necessary, adjust and/or lubricate it. Check the tire surface, the inflation pressure, wear and any damage. Remove any foreign matter that may be stuck in the tread grooves. Lubricate the joints and adjust the stroke if necessary. Check the operation of the clutch, the idle stroke of the control lever, the fluid level and any leaks. If necessary, top up the fluid; the clutch must operate without jerking and/or slipping. Make sure that the steering rotates smoothly, without any clearance or slackening. Make sure that when the stand is let up or down there is no friction and that the spring tension brings it back to its normal position. Make sure that the safety switch operates correctly. [. . . ] RAD DK T. M. P. SF TUONTI NAKKILA OY R RO GROUP INT. CSI Z. A. O. ITALMOTO USA APRILIA U. S. A. , INC. J APRILIA JAPAN CORP. AUS JOHN SAMPLE GROUP PTY LTD. use and maintenance RSV mille TUONO - RSV mille R TUONO 147 IMPORTERS NZ MOTORCYCLING DOWNUNDER LTD. 35, Manchester Street - P. o. B. 0064-3-3667580 - Email: guzzi@motorcycling-nz. co. nz Old Pretoria Road - Wynberg - Johannesburg Tel. 0027-11-7868482 - Email: motovelo@betech. co. za San Jeromino - 64640 - 552 Monterrey N. L. [. . . ]