User manual APRILIA SCARABEO 125-200 2007

[. . . ] Any mention to the use of the vehicle with passenger is to be intended as referred only to the countries where this is allowed. In the text and figures the symbols 3 2 preceded by the symbol of the model (. /) refer exclusively to the model indicated. 7!2. ). '3 02%#!54)/. 3 '%. %2!, !$6)#% Before starting the engine, carefully read this manual and in particular the section "SAFE DRIVE". [. . . ] Never bite, suck, chew or swallow any part of the vehicle for any reason. aCAUTION If not expressly indicated otherwise, for the reassembly of the units repeat the disassembly operations in reverse order. In case any maintenance operation has to be carried out, it is advisable to use latex gloves. Normally, the routine maintenance operations can be performed by the user; however, in some cases the use of specific tools and technical expertise may be required. If you need assistance or technical advice, consult your aprilia Official Dealer, who can ensure you prompt and accurate servicing. Ask your aprilia Official Dealer to test the vehicle on the road after a repair or periodic maintenance operation. In any case, personally carry out the "Preliminary checking operations" after any maintenance operation, see p. 33 (PRELIMINARY CHECKING OPERATIONS). use and maintenance Scarabeo 50 - Scarabeo 100 43 2%'5, !2 3%26)#% ). 4%26!, 3 #(!24 OPERATIONS TO BE CARRIED OUT BY THE APRILIA Official Dealer (WHICH CAN BE CARRIED OUT EVEN BY THE USER) Components Battery / electrolyte level . Spark plug Carburettor - idling Air cleaner Speed variator air cleaner / Brake locking operation Light system Stop light switches Brake fluid 2 stroke oil . 2 stroke oil / Light direction - operation Tyres - inflation pressure Brake pad wear C C C C C C C every 500 km (312 mi): C every 400 km (250 mi): C C every month: R every 2000 km (1250 mi): C After running-in [500 km (312 mi)] C C R C Every 4000 km (2500 mi) or 8 months C C C P P S Every 8000 km (5000 mi) or 16 months C = check and clean, adjust, lubricate or change, if necessary; P = clean; S = change; R = adjust. Carry out the maintenance operations more frequently if you use the vehicle in rainy and dusty areas or on uneven ground. 44 use and maintenance Scarabeo 50 - Scarabeo 100 OPERATIONS TO BE CARRIED OUT BY THE APRILIA Official Dealer Every 4000 km Every 8000 km (2500 mi) (5000 mi) or 8 months or 16 months Variator belt C Steering bearings and steering C C Wheel bearings C P Removal of deposits from the exhaust . Braking systems C C every 20000 km (12500 mi):P (outside cleaning) Cylinder cooling system / Rear brake cam pin greasing 3 C Brake fluid every 2 years: S Mixer / accelerator operation C C every 3000 km Transmission oil . S (1875 mi): C every 12000 km (7500 S C Transmission oil / mi) or every 2 years: S Wheels / tyres C Nut, bolt, screw tightening C C Front and readr suspension C C 2 stroke oil reserve warning light C C Brake fluid bleeding C Fuel pipe every 4000 km (2500 mi): C / every 4 years: S Braking system pipe every 4000 km (2500 mi): C / every 4 years: S 2 stroke oil pipe C C C C Rear brake shoe wear 3 C = check and clean, adjust, lubricate or change, if necessary; P = clean; S = change; R = adjust. N Move the rear brake cable (2) sidewards and keep it in this position with your hand. CLEANING aWARNING Do not use petrol or inflammable solvents to wash the filtering element, in order to avoid fires or explosions. N aCAUTION Pay attention to the correct position of the lower cover (3) and the filtering element (4), in such a way as to be able to reposition them correctly (the filtering element must be inserted with the side made of black rigid spongy material facing the front of the vehicle). N N N Wash the filtering element (4) with clean, non-inflammable solvents or solvents with high volatility point, then let it dry thoroughly. Apply a filter oil on the whole surface of the filtering element. Withdraw the lower cover (3) from below and take the gasket (5). Withdraw the filtering element (4). 48 use and maintenance Scarabeo 50 - Scarabeo 100 2%-/6). ' 4(% 7(/, % !)2 #, %!. %2 #!3). ' . 30%%$ 6!2)!4/2 !)2 #, %!. %2 / CLEANING Carefully read p. 43 (MAINTENANCE). N N N Carefully read p. The air cleaner should be inspected and cleaned every 8000 km (5000 mi), depending on the conditions of use. If the vehicle is used on dusty or wet roads, the cleaning operations should be carried out more frequently. To clean the filtering element it is necessary to remove it from the vehicle. N Check the filtering element (5) and change it if necessary. aWARNING Do not use petrol or inflammable solvents to wash the filtering element, in order to avoid fires or explosions. Do not use any additive or liquid to clean the filtering element, in order to avoid the formation of moisture inside the speed variator. Use only compressed air. N Remove the footboard, see p. Unscrew and remove the screws (1) and (2), taking the relevant washers. NOTE Upon reassembly, position the cable guide (3) correctly. N N Loosen the screw (4) of the air manifold clamp. [. . . ] Spark plug gap. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Engine idle rpm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . /. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . CDI 14° ± 2° before T. D. C. to 4000 rpm; 14° over 4000 rpm NGK BR7 HS NGK BR8 HS 0. 5 - 0. 6 mm 1800 ± 100 rpm 1400 ± 100 rpm . [. . . ]