User manual APRILIA SCARABEO 250 I.E. 2006

[. . . ] In the text and figures the symbols 3 preceded by the symbol of the model (. /) refer exclusively to the model indicated. 7!2. ). '3 02%#!54)/. 3 '%. %2!, !$6)#% Before starting the engine, carefully read this manual and in particular the section "SAFE DRIVE". Your and other people's safety depends not only on your quickness of reflexes and on your agility, but also on what you know about the vehicle, on its efficiency and on your knowledge of the basic information for "SAFE DRIVE". [. . . ] Key = check and clean, adjust, lubricate or change, if necessary; = clean; = change; = adjust. Component Battery - Terminal fastening - Electrolyte level x Battery - Terminal fastening y Spark plug Carburettor - idling Air cleaner Speed change gear air filter y Accelerator operation Brake locking operation Light system Stop light switches Brake fluid 2 stroke oil x 2 stroke oil y Headlight beam direction - operation Wheels/tyres and inflation pressure Rear brake shoe wear t Front and rear brake pad wear After running- Every 4000 Every 8000 in [500 km km (2500 mi) km (5000 mi) (312 mi)] or 12 months or 24 months ­ ­ ­ ­ ­ ­ ­ ­ ­ ­ ­ ­ NOTE Carry out the maintenance operations more frequently if you use the vehicle in rainy and dusty areas or on uneven ground. every 500 km (312 mi): every 400 km (250 mi): ­ ­ every month: ­ every 2000 km (1250 mi): 46 use and maintenance Scarabeo 50 - Scarabeo 100 OPERATIONS TO BE CARRIED OUT BY THE APRILIA Official Dealer. Key = check and clean, adjust, lubricate or change, if necessary; = clean; = change; = adjust. Component Rear shock absorber Battery - Terminal fastening Transmission cables and controls Variator belt Steering tube bearings and steering slack Wheel bearings Brake discs Removal of deposits from the exhaust Piston rings Accelerator operation - Mixer General running of the vehicle Braking systems/brake discs Cylinder cooling system Rear brake cam pin greasing Brake fluid Fork oil and oil seal After running-in Every 4000 km [500 km (312 (2500 mi) or 12 mi)] months ­ ­ ­ Every 8000 km (5000 mi) or 24 months NOTE Carry out the maintenance operations more frequently if you use the vehicle in rainy and dusty areas or on uneven ground. x xy t Transmission oil Transmission oil x y Rear pulley pins Movable/fixed front pulley Variator front pins and guides Wheels/tyres and inflation pressure Nut, bolt, screw tightening 2 stroke oil reserve warning light Fuel pipe Braking system pipe Mixer oil pipe Clutch wear ­ every 6000 km: ­ ­ ­ ­ ­ every 12000 km (7500 mi): ­ ­ every 20000 km (12500 mi): (outside cleaning) ­ ­ every 2 years: every 12000 km (7500 mi): every 3000 km every 12000 km (7500 (1875 mi): mi) or 2 years: every 12000 km (7500 mi) or 2 years: every 12000 km (7500 mi): every 6000 km (3750 mi): every 6000 km (3750 mi): ­ ­ ­ every 4000 km (2500 mi): / every 4 years: ­ every 4 years: every 2 years: ­ ­ use and maintenance Scarabeo 50 - Scarabeo 100 ­ ­ 47 )$%. 4)&)#!4)/. It is a good rule to write down the frame and engine numbers in the space provided in this manual. The frame number can be used for the purchase of spare parts. FRAME NUMBER The frame number is stamped on the central tube of the frame. To be able to read it, it is necessary to remove the cover (1). Frame no. NOTE Do not alter the identification numbers if you do not want to incur severe penal and administrative sanctions. In particular, the alteration of the frame number results in the immediate invalidity of the guarantee. 48 use and maintenance Scarabeo 50 - Scarabeo 100 ENGINE NUMBER . The engine number is stamped near the lower support of the rear shock absorber. Engine no. ENGINE NUMBER / The engine number is stamped on the rear side, near the rear brake adjuster. Engine no. use and maintenance Scarabeo 50 - Scarabeo 100 49 !)2 #, %!. %2 . Carefully read p. Check the conditions of the air cleaner and clean it monthly or every 4000 km (2500 mi), depending on the conditions in which the vehicle is used. Grasp the air manifold in correspondence with the clamp and pull it, thus removing the whole air cleaner casing. 52 use and maintenance Scarabeo 50 - Scarabeo 100 30%%$ 6!2)!4/2 !)2 #, %!. %2 / CLEANING Carefully read p. The air cleaner should be inspected and cleaned every 8000 km (5000 mi), depending on the conditions of use. If the vehicle is used on dusty or wet roads, the cleaning operations should be carried out more frequently. To clean the filtering element it is necessary to remove it from the vehicle. N Check the filtering element (1) and change it if necessary. aWARNING Do not use petrol or inflammable solvents to wash the filtering element, in order to avoid fires or explosions. Do not use any additive or liquid to clean the filtering element, in order to avoid the formation of moisture inside the speed variator. Use only compressed air. N aCAUTION DO NOT OIL THE FILTERING ELEMENT, since the oil may get into the belt case and damage the belt or make it slip. Clean the filtering element (1) by means of a pressurized air jet. use and maintenance Scarabeo 50 - Scarabeo 100 53 &2/. 4 7(%%, DISASSEMBLY N Position the vehicle on the centre stand on firm and level ground. N N NOTE aCAUTION The disassembly and reassembly of the front wheel may be difficult for unskilled operators. If necessary, contact an APRILIA Official Dealer. If you want to perform these operations personally, keep to the following instructions. While disassembling and reassembling the wheel, be careful not to damage the brake pipes, the discs and the pads. Prepare a support with base measuring 200 x 200 mm, whose height should be 270 mm for the . and 230 mm for the / N Support the front wheel and manually withdraw the wheel pin (3). [. . . ] Fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Generator (with permanent magnet) . . . . . . . . . . . . . . . . . . . . . . . . Low/high beam bulb . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Rear parking light Direction indicator bulbs. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]