User manual APRILIA SCARABEO50I.E DEALER INSTRUCTION

[. . . ] See the PRELIMINARY CHECK LIST IN THE VEHICLE OPERATION AND MAINTENANCE HANDBOOK. Failure to carry out these checks may lead to serious injury or damage to the vehicle. Very little time is required, and the benefits in terms of safety are enormous. Make sure the nut (1) is tight. The following warning messages are used on all the instruction sheets to draw your attention to the situations described below. [. . . ] · Use the same plug (3) to stop up battery holes. FITTING THE STORAGE BOX 1 BATTERY Battery electrolyte is toxic, caustic and the contact with the skin may cause serious burns, since it contains sulfuric acid. Wear protective clothing, a face shield and/or tight fitting goggles when working around the battery. In case of contact with the skin, flush immediately with plenty of water. In case of contact with the eyes, flush with plenty of water for at least 15 minutes. If the electrolyte is accidentally swallowed, drink large quantities of water or milk, and then milk of magnesia or vegetable oil. Immediately consult a health professional. The battery gives off noxious and explosive gases; keep it away from cigarettes, flames, sparks and any other source of heat. During the recharging or the use, make sure hat the room is properly ventilated and avoid inhaling the gases released during the recharging. Do not tip the vehicle too much, or tip the battery too much, to avoid electrolyte leaking out. Follow the assembly instructions for the storage box. · Fit the spacer bushes (1) in the carrier housings and the inner street case housings. · Secure the street case to the carrier with the screws TBEI M6X35 (2) and self-locking nuts M6 (3). Screw (2) tightening torque: 7. 37 ftlb (10 Nm). 3 CAUTION The battery liquid is corrosive. Do not pour or sprinkle it, particularly on plastic parts. When the battery has been removed it must be placed in a safe place out of the reach of children. The battery is very dangerous and may cause serious injury or death. 7 SCARABEO 50 i. e. SCARABEO 50 i. e. DEALER INSTRUCTION SHEET 3 DEALER INSTRUCTION SHEET SX DX 2 1 6 · Fit screws TCEI M 6x35 (6) of the wheel pin fork clamp. Screw (6) tightening torque: 8. 85 ftlb (12 Nm). [. . . ] Carry out the same operations for the left-hand mirror. Pag. 3 SCARABEO 50 i. e. SCARABEO 50 i. e. DEALER INSTRUCTION SHEET A DEALER INSTRUCTION SHEET 1 FITTING THE FRONT WHEEL 2 3 · Place a stand under the vehicle · To fit the front wheel, remove the brake lever (1) by unscrewing TEF M 8x30 (2) and the washers. · Fit the wheel and the mileage counter drive gear (3) positioning the tongue (A) in the hub housing. DANGER Before carrying out any maintenance operation or inspection of the front wheel, if possible hoist the vehicle onto a solid and level surface with suitable equipment. [. . . ]