User manual AYP 8196A99 PARTS-LIST

[. . . ] THROTTLE CRANK, BELL SCREW, SHOULDER NUT, SQUARE SPRING, COMPRESSION SPRING, GOVERNOR SPRING, GOVERNOR IDLE GEAR, GOVERNOR OIL SLINGER ASSEMBLY WASHER, THRUST PLATE ASSEMBLY, GOVERNOR CONTROL SCREW, PAN HEAD LEVER ASSEMBLY, GOVERNOR WASHER WASHER, GOVERNOR CRANK, INSIDE SHIELD, SPITBACK FILTER, FUEL CONNECTOR, IMPULSE PUMP SCREW, SEMS SCREW, HEX HEAD SCREW, HEX HEAD HOUSING, BLOWER, RED SCREW SHIELD, CYLINDER SHIELD, CYLINDER SCREW COVER, AIR GUIDE COVER, AIR GUIDE MOTOR, STARTER BOLT BRUSH SET NUT, HEX ARMATURE GROUP MAGNETRON IGNITION Page 18 of 47 8196A99 (1999) BRIGGS AND STRATTON ENGINE Ref # 334 337 356 358 363 383 391 392 394 414 422 432 434 435 445 468 474 482 510 523 524 525 528 534 535 537 544 552 552A 556 562 567 569 572 573 592 601 615 615A 616 634 634A 635 642 643 653 726 741 783 801 802 803 819 842 847 851 858 859 Part Number 94731 802592 494705 495868 19203 89838 280197 261395 272638 220680 222875 221377 223688 93829 394019 497908 393474 93621 497606 494947 271157 495348 393815 94823 272490 271411 497603 262332 262331 93585 93853 94811 272645 224816 491304 92278 93053 94296 263080 491530 271013 491287 66538 225008 496700 93585 391362 262989 280104 394860 497607 497604 94675 270920 495715 493880 270989 271025 Qty Description SCREW, SEMS PLUG, SPARK WIRE, STOP IN GASKET SET PULLER, FLYWHEEL WRENCH SPARK PLUG BODY, PUMP SPRING, PUMP DIAPHRAGM WASHER CLAMP, OIL FILLER CAP, SPRING COVER, DIAPHRAGM SCREW, DIAPHRAGM COVER CARTRIDGE AIR CLEANER SCREEN, ROTATING STATOR, ALTERNATOR, DUAL CIRCUIT SCREW, SEMS DRIVE, STARTER CAP AND DIPSTICK SEAL, FILLER TUBE TUBE, OIL FILLER HOSE (CUT TO SUIT) SCREW ROUND HEAD ELEMENT, FILTER GASKET AIR CLEANER ARMATURE, STARTER LOWER BUSHING, GOVERNOR UPPER BUSHING GOVERNOR SCREW, HEX HEAD BOLT, GOVERNOR LEVER SCREW, HEX HEAD GASKET, CRANKCASE BAFFLE, AIR, CYLINDER #2 BACK PLATE ASSEMBLY NUT, HEX CLAMP, HOSE, GREEN RETAINER, E-RING RETAINER CRANK, GOVERNOR WASHER, THROTTLE SHAFT SEAL, GOVERNOR SHAFT ELBOW, SPARK PLUG COVER, AIR CLEANER CARTRIDGE PLATES AIR CLEANER SCREW, HEX HEAD GEAR, RING GEAR, TIMING GEAR, STARTER CAP, DRIVE P/N CONFLICT - CHECK WITH SUPPLIER HOUSING, STARTER SCREW, HEX HEAD SEAL, OIL FILLER CAP DIPSTICK & TUBE ASSY TERMINAL, IGNITION CABLE DIAPHRAGM, DAMPING GASKET, CARBURETOR Page 19 of 47 8196A99 (1999) BRIGGS AND STRATTON ENGINE Ref # 860 861 868 869 870 871 871 877 881 955 1005 1006 1019 1090 2500 Part Number 261358 393397 497212 261463 213316 261961 231218 393456 495901 397882 281053 224901 496726 97605 42E707-2631 498543 Qty Description SPRING, DIAPHRAGM PUMP REPAIR KIT SEAL, VALVE SEAT, INTAKE VALVE, STANDARD SEAT, EXHAUST VALVE, STANDARD GUIDE, EXHAUST VALVE GUIDE, INTAKE VALVE DIODE & CONNECTOR ASSY COVER PLATE PLUG & SEAL, SOLENOID FAN, FLYWHEEL RETAINER, FAN LABEL KIT RETAINER, BRUSH ENGINE SHORT BLOCK Page 20 of 47 8196A99 (1999) CHASSIS AND ENCLOSURES Page 21 of 47 8196A99 (1999) CHASSIS AND ENCLOSURES Ref # 1 2 3 4 5 6 8 9 10 11 12 13 14 15 16 17 18 20 23 24 25 26 28 29 30 31 33 34 35 37 38 39 44 47 51 52 53 54 55 57 58 74 108 140 145 Part Number 165480 140356 17490612 19131216 155272 155923 126471X 161938X012 72140608 156682 145660 157230 17490608 74180512 73510500 73510500 126938X 156437 124028X 74780616 19131312 73800600 157373 140273X599 140002X505 137113 145244X505 145243X505 72110606 17490508 139886 139887 140675 105531X 73800400 19091416 144697 161464 144696 74780412 140547 73680600 74760612 158418 156524 Qty Description CHASSIS. STAMPING SUB= 145009 SCREW WASHER BUMPER-HOOD/DASH SADDLE "CLIP, INSULATOR" DASH. SILKSCREEN SUB= 72110608 PANEL ASM DASH LH CLIP. TINNERMAN PANEL DASH RH SCREW LT SCREW NUT NUT SUB= 532126938 "PLATE-MTG, BATT/FU" SUB= 532124028 BOLT WASHER NUT GRILLE-MS428 LENS. GRILLE. PRIVATE LABEL FENDER. PNT. [. . . ] "BOLT, HEX" GRIP SUB= 125925X SUB= 125925X SPRING T LINK. LIFT. LH. GTV LINK. LIFT. RH. GTV. SUB= 85902 LEVER. ASM. LIFT. RH LINK. FRONT NUT TRUNION NUT LTV ARM SUSP REAR RETAINER SPRING NUT T WASHER SPRING T SUB= 3145 SUB= 532126971 NUT KNOB INF 3/8-16 TRUNNION BEARING PVT LH NUT. CROWNLOCK. 3/8 POINTER-INDICAT "PLUG, HOLE" SCREW STOP. OVER. CENTER WASHER HEIGHT INDICATOR SUB= 73690600 WASHER GT BOLT E-RING WASHER NUT. HXFLG. LOCK. NUT PUSH M Page 33 of 47 8196A99 (1999) MOWER DECK Page 34 of 47 8196A99 (1999) MOWER DECK Ref # 1 3 5 6 8 9 10 11 12 13 14 15 16 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 58 59 60 61 62 63 67 68 69 Part Number 164210 138457 4939M 130832 850857 10030600 140296 163819 129895 137553 137152 110485X 140329 72140505 132827 145055 73680500 134753 131267 105304X 149287 110452X 157788 19111016 131491 157722 129963 153531 137266 144945 17490628 19131316 131494 156086 144917 137273 17490620 122052X 144949 133943 145059 137729 144959 158818 73680600 72110612 153390 156493 19131312 156488 157034 156722 161315 131870 156473 74760512 156487 73350600 Qty Description "DECK. ASM. MOWER46""" BRKT. ASM. SW. 44/50 SUB= 85902 SUB= 130833 BLADE BOLT SUB= 10040600 WASHER. HARD. BLADE "BLADE MULCH 46""" BEARING. BALL SHAFT. ASM. W/BRNG HOUSING. MAND. 44. V BEARING STRIPPER RND MWR BOLT BOLT SHD 5/16-18 BAFFFLE. VORTEX. 46 SUB= 73690500 STIFFENER BRKT DEFLECTOR BRKT CAP-SLEEVE LT SUB= 123713X NUT PUSH M SHIELD DEFLECTOR WASHER HINGE ROD "SCREW-THD ROLL, WA" WASHER PULLEY. MAND. 36/46 SUB= 139729 ANCHOR. SPRING. 46 SCREW LT WASHER FLAT IDLER PULLEY "KEEPER BELT, IDLER" PULLEY. DRV. DCK. 46 "SPRING. SEC. 44""VEN" SCREW SPACER RETAINER ARM. IDLER. DECK. 46 HARDENED WASHER COVER. MANDREL. 46 SCREW. 1/4-20X5/8 BELT-V. SEC. 46. KEL V BELT MOWER SUB= 73690600 BOLT. 3/8-16X1. 50 WASHER. FELT. "PULLEY IDLER, FLAT" WASHER "LINK BRAKE, 43""" "GUIDE BELT, 46""MOW" ARM ASM BRAKE BOLT. SHOULDER. 5/16-18 RETURN SPRING "BRKT ROD, CLUTCH" BOLT SUB= 157060 NUT Page 35 of 47 8196A99 (1999) MOWER DECK Ref # 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 92 101 102 103 104 105 106 116 117 118 119 120 126 127 128 129 Part Number 142028 133551 19131316 76020412 156474 159145 160570 127845 127498 153701 121748X 12000029 4497H 128903 162132 10040600 158565 158373 74780616 73800600 145579 71161010 10071000 19061216 160793 2029J 4898H 105455X 73930600 19121414 19171512 156472 146763 6266H 19133808 143651 164846 Qty Description TRUNION ADJ PIVOT ROD WASHER COTTER PIN LINK CLUTCH ARM EXTENSION LEVER. ASM. CLUTCH SPRING KEEPER BUSHING SPRING. CLUTCH. MWR WASHER RING RETAINER M SHOULDER BOLT KNOB. RD. 7/16-14 LOCKWASHER "BOLT CARR, SH" BRACKET. EXTENSION BOLT NUT COVER. MULCHING. SCREW LOCKWASHER WASHER #10 LATCH ASSY. BAGGER WELDNUT BOLT M WHEEL. GAGE. BLK. PL LOCKNUT WASHER WASHER ARM IDLER PULLEY. IDLER. 4. 25 WASHER . T WASHER T MANDREL SERV ASM DECK COMPLETE Page 36 of 47 8196A99 (1999) SCHEMATIC Page 37 of 47 8196A99 (1999) SCHEMATIC Ref # Part Number REFER Qty Description REFER TO IMAGE Page 38 of 47 8196A99 (1999) SEAT ASSEMBLY Page 39 of 47 8196A99 (1999) SEAT ASSEMBLY Ref # 1 2 5 6 7 10 12 13 14 15 16 17 21 22 23 24 25 26 27 28 Part Number 140117 140551 145006 73800600 124181X 155925 121246X 121248X 72050412 134300 121250X 123976X 153236 73800500 74780814 19171912 127018X 10040800 17490608 150176 Qty Description SEAT. 2400/1416. BK BRACKET PVT SEAT CLIP. PUSH-IN. HING NUT SPRING COMPRESSIO PAN-SEAT BRKT SWITCH BUSHING BOLT-RD HD SQ NK SPLIT SPACER SPRING SUB= 73900400 "BOLT, SHOULDER" NUT BOLT WASHER "BOLT, SHOULDER" LOCKWASHER SCREW LT BOLT. 5/16-18. UNC Page 40 of 47 8196A99 (1999) STEERING ASSEMBLY Page 41 of 47 8196A99 (1999) STEERING ASSEMBLY Ref # 1 2 3 4 5 6 7 8 9 10 11 13 15 17 18 19 22 23 25 26 27 28 29 30 32 36 37 38 39 40 41 42 43 44 46 47 51 54 56 62 63 65 66 67 68 79 80 Part Number 140044 154427 156486 157475 6266H 121748X 19272016 12000029 3366R 156438 10040600 154779 73901000 156546 57079 160395 165857 165851 154406 126847X 136874 19131416 17490612 76020412 130465 155099 152927 140045 19133808 7810H 100711L 145054 121749X 153720 121232X 6855M 73800500 74780520 19131210 167902 74780616 154780 154404 74781044 154429 19132012 74950612 Qty Description WHEEL STR AYP BLK AXLE ASM "SPINDLE ASM, RH" "SPINDLE AMS, LH" WASHER . T WASHER WASHER RING COL. DRAGLINK-STAMPED LOCKWASHER BEARING AXLE "NUT-LOC, FLANGE LT" SHAFT ASM STEERIN THRUST WASHER SUPPORT. SHAFT. STEER SCREW. HX. WSH. HD SHAFT. ASM. PITMAN BRKT-STEERING BUSHING. DRAGLINK GEAR SECTOR WASHER SCREW COTTER PIN TIE ROD BUSHING. STEERING "SCREW-TT, 10-32 FL" CAP STEER AYP WASHER T GRIPCO NUT ADAPTER LT BOOT. STEER. PL WASHER EXT SHAFT STEERIN CAP ZERK M NUT BOLT WASHER KIT. STEER. ASM BOLT SPACER AXLE "BEARING-ARM, PITMA" BOLT BRACE AXLE WASHER BOLT. HX. NYLON3/8-16X3/ Page 42 of 47 8196A99 (1999) TRANSAXLE PEERLESS Page 43 of 47 8196A99 (1999) TRANSAXLE PEERLESS Ref # 1 2 3 4 5 6B 7 8 9 10 11 12 13 14 15 16 17 18 18A 20 21 22 24 25 25A 26 27 28 29 30 31 31A 31B 36 37 38 39 40 41A 42 42A 43 44 45 46 47 48 49 50 51 52 53 54 57 58 59 60 61 Part Number 772098A 780155 770088 776291 776275 778247 778253 792180 784352 784375 778246 778245 778198 778197 778248 786027 786019 786121 786122 792077 792078 792079 780071 792129A 792073A 792018 792018 788040 780072 780108 780128 780107 780042 790043 790007 799021 786026 792076A 790047 792073A 792085A 792075 790025 786067 786086 774832 774831 778216A 778206A 778205A 778204A 778203A 778273 778199 778200 778201 778202 778208 Qty Description COVER TRANSAXLE BEARING NEEDLE CASE TRANSAXLE SHAFT COUNTER SHAFT, OUTPUT, 9T GEAR, OUTPUT, 35T GEAR, SPUR, 15T SHIFT KEY COLLAR, SHIFTER SHIFT FORK GEAR BEVEL, 33T BEVEL PINION, 13T GEAR BEVEL PINION, 10T GEAR, RING, 31T BLOCK DRIVE PIN DRIVE SPACER, . 350/. 340 THICK SPACER, . 276/. 268 THICK BALL STEEL, 5/16" DIA. [. . . ] SUB= 138756 REFER TO PARTS IMAGE TUBE. 23X8/10-12 HUB CAP SEALANT. TIRE 10 OZ. [. . . ]