User manual BONFIGLIOLI BS

[. . . ] Make sure that the motor rests in a stable manner and will not roll (in the case of flanged motors). Storage Observe the following instructions to ensure correct storage of products: a. Do not store outdoors, in areas exposed to weather or with excessive humidity. Always place boards in wood or other material between floor and products, to avoid direct contact with the floor. [. . . ] check that operation is smooth and vibration-free; 4. For letting the starting capacitor discharging allow for a minimum 6 seconds rest time before reconnecting the motor; 5. if operation is satisfactory, apply the load to the motor while checking on values of absorbed current, power and voltage. Abnormal operations such as over current, overheating, noise, or vibrations, may cause serious damage or hazardous conditions. In these cases, cut power and notify maintenance personnel immediately. 7 MAINTENANCE Before any intervention, the motor, auxiliary circuits and/or accessories must be disconnected from the mains. In particular: check disconnection from the electrical mains, provide suitable protections from exposed live parts, duble check that accidental restarts are not possible under any circumstances. It is recommended that periodical checks of motor operating conditions are scheduled as a routine maintenance practice. Check particularly on the following: check that operation is smooth and absorbed current within rated value; keep motor clean and fan cowl unobstructed by accumulation of dust or foreign particles; check that seal rings are in good condition; check that lead-in wires and all wirings are safely and tightly secured; If condensate draining holes are provided, remove periodically the screws that close the holes and allow the condensate to drain. On installing the motor make sure that the drain hole is located at the lowest point. standard bearings are grease packed for life and in general no periodical maintenance is required; it is good practice however to check their condition and eventually replace them after approx. The motor does not have to be removed for normal inspections unless the bearings need to be replaced. In this case, the operations should be performed by specialised personnel and with appropriate tools. 5. 6 8 SPARE PARTS LIST N. 1010 1030 1050 1070 1150 1100 1180 1200 1230 6234 6250 6020 6030 6050 6060 6070 6080 6405 6406 Description Stator winding Rotor shaft Flange (B5/B14) Motor shield Fan Tie-rods Fan cowl Terminal box Terminal box gasket Threaded plug Terminal board Bearing DE Bearing NDE Compensating ring Key DE Seal ring V-ring Run capacitor Starting capacitor (DC type only) kit KSM KSA 7 INDEX OF REVISIONS DOCUMENT R0 SECTION DESCRIPTION 8 COD. 1281 R0 INDUSTRY PROCESS AND AUTOMATION SOLUTIONS Worldwide Bonfiglioli Worldwide & BEST Partners AUSTRALIA BONFIGLIOLI TRANSMISSION (Aust) Pty Ltd. (+61) 2 8748 4400 - Fax (+61) 2 9748 8740 P. o. Box 6705 Silverwater NSW 1811 www. bonfiglioli. com. au - sales@bonfiglioli. com. au AUSTRIA MOLL MOTOR GmbH Industriestrasse 8 - 2000 Stockerau Tel. (+43) 2266 63421+DW - Fax (+43) 6342 180 - Tlx 61 32 22 348 Molla www. mollmotor. at - office@mollmotor. at BELGIUM N. V. Culliganlaan 3 - 1831 Machelem Diegem Tel. 0032 2 7204880 - Fax 0032 2 7212827 - Tlx 21930 Escopo B www. escotrans. be - info@escotrans. be BRASIL ATI BRASIL Rua Omlio Monteiro Soares, 260 - Vila Fanny - 81030-000 Tel. (+41) 334 2091 - Fax (+41) 332 8669 www. atibrasil. com. br - vendas@atibrasil. com. br CANADA BONFIGLIOLI CANADA INC. 2-7941 Jane Street - Concord, ONTARIO L4K 4L6 Tel. (+1) 905 7384466 - Fax (+1) 905 7389833 www. bonfigliolicanada. com - sales@bonfigliolicanada. com CHINA BONFIGLIOLI DRIVES (SHANGHAI) CO. 8 Building, 98 Tian Ying Road - Qingpu District, Shanghai, PRC 201700 Tel. [. . . ] Zona Franca sector C, calle F, n°6 08040 Barcelona Tel. (+34) 93 4478400 - Fax (+34) 93 3360402 www. tecnotrans. com - tecnotrans@tecnotrans. com SOUTH AFRICA BONFIGLIOLI POWER TRANSMISSION Pty Ltd. 55 Galaxy Avenue, Linbro Business Park - Sandton Tel. (+27) 11 608 2030 OR - Fax (+27) 11 608 2631 www. bonfiglioli. co. za - bonfigsales@bonfiglioli. co. za SWEDEN BONFIGLIOLI SKANDINAVIEN AB Kontorsgatan - 234 34 Lomma Tel. [. . . ]