User manual DAELIM ROADWIN FI CATALOG

[. . . ] OWNER S MANUAL IMPORTANT NOTICE WELCOME Thank you for purchasing an Daelim vehicle. OPERATOR AND PASSENGER This motorcycle is designed to carry the operator and one passenger. WARNING Attempting to change the pre-set maximum speed may cause danger and will void the Daelim warranty. ON-ROAD USE This motorcycle is designed to be used only on the road. READ THIS OWNER'S MANUAL CAREFULLY Pay special attention to statements preceded by the following words: WARNING Indicates a strong possibility of severe personal injury or death if instructions are not followed. CAUTION Indicates a possibility of personal injury or equipment damage if instructions are not followed. NOTE Gives helpful information. This manual is an important and integral part of your vehicle. [. . . ] If the side stand is up, the engine can be started in neutral or in gear with the clutch lever pulled in. After starting with the side stand down, the engine will shut off if the transmission is put in gear before raising the side stand. <PREPARATION> Before starting, insert the key, turn the ignition switch ON and confirm the following: The transmission is in NEUTRAL (neutral indicator light ON) 2. Once engine is started, pull and release throttle grip repeatedly to run engine idle until engine is heated. Check to see if the MIL is illuminat for 3 second. <WHEN ENGINE IS COLD > <WHEN ENGINE IS HOT > 1. Close throttle grip and press starter button. (If engine is not started with 1-2 times trial. If engine is not started with throttle grip closed, open throttle grip approximately 1/8 to 1/4 and press starter button. WARNING Never run the engine in an enclosed area. The exhaust contains poisonous carbon monoxide gas that can cause loss of consciousness and lead to death. CAUTION Do not keep the starter button pressed for more than 5 seconds at a time. Release the starter button for approximately 10 seconds before pressing it again. 1. Close throttle grip, and press starter button. 27 IF ENGINE CANNOT BE STARTED RUNNING-IN During initial running-in newly machined surfaces will be in contact with each other and these surfaces will wear in quickly. Running-in maintenance at 1, 000km is designed to compensate for this initial minor wear. Timely performance of the running-in maintenance will ensure optimum service life and performance from the engine. Never labour the engine with full throttle at low engine speeds. This rule is applicable not only during running-in but at all times. Maximum continuous engine speed during the first 1, 000km must not exceed 5, 000 rpm. It is possible that starting will be more difficult if the vehicle has not been used for a long period of time or if the fuel hole is plugged up (starting problems even when there is sufficient fuel in the fuel tank may be an indication of a plugged fuel hole). When this happens, do not rotate the throttle grip and try the starter button a few times. If engine cannot be started or vehicle does not move, check the followings. Are you operating in accordance with the instructions given in user's manual? If starter motor is not running due to battery consumption, charge the battery. If the MIL blinks continously when the main key is on, inquiry to the daelim dealer. NOTE Do not run engine idle unreasonably. This not only wastes fuel but also adversely affects engine. If starter button is pressed in gear position, vehicle may bring out to fall. Make sure gear is in neutral position prior to starting engine. CAUTION Running the engine beyond recommended maximum engine speed (the beginning of the tachometer red zone) can damage the engine. 28 RIDING 1. After the engine has been warmed up, the motorcycle is ready for riding. [. . . ] Do not drive excessively long distance and take enough break. If any abnormality is found, stop driving and contact service center to inspect the vehicle. Restart the vehicle after 2~3 min when it is turned over. Always turn on the headlight at night. 53 STARTING Prior to starting always look around to avoid accident. Get on the vehicle after pulling back the stand. Start driving slowly after turning on the winker and releasing the brake while ensuring the safety around the vehicle. CAUTION Return the side stand to its original position. [. . . ]