User manual DAHON SINGLE DIGIT 7-TI

[. . . ] Tighten the mounting bolt. 2 CHECK THE PAD SPACING Check that the brake arms are approximately parallel when the brake pads are on the rim. There are 4 spacing options: 3mm, 4mm, 5mm, and 6mm. If the arms aren't parallel, check the chart on the back for corresponding washer configurations. SINGLE DIGIT 7/Ti INSTALLATION AND OPERATION INSTRUCTIONS ® Follow these instructions carefully. [. . . ] DO NOT push the boot all the way up to the link. The Avid noodle & boot are designed to be removed from the link without having to disengage the boot. 1mm CORRECT INCORRECT Tighten Pad Fixing Nut to: 6 - 8 Nm (52 - 69 in lb) 11D7/Ti-02/02 6 ANCHOR THE CABLE Pull the cable tight enough to have clearance of 1 - 1. 5mm, per side, between the rim and the brake pads. Tighten the cable anchor bolt to the specified torque. Tighten Cable Anchor Bolt to: 7 CENTER THE BRAKE Center the brake by adjusting the spring tension adjusters. Turn each spring adjuster screw with a 3mm hex wrench clockwise to increase spring tension. 8 TEST THE SYSTEM With two fingers, squeeze the brake lever firmly about a dozen times to ensure the cables are seated properly and operate smoothly. Make sure the cable has not slipped at the cable anchor bolt. Re-torque if necessary. Tighten Cable Anchor Bolt to: LIMITED WARRANTY Avid, LLC (Avid) warrants to the original consumer purchaser of every Avid product that the product shall be free from defects in workmanship and materials for a period of one (1) year from the original date of purchase. The sole remedy under this warranty is limited to, at Avid's sole discretion, repair or replacement of the defective product. Labor and shipping costs are excluded from this warranty. This warranty only applies to the original consumer purchaser and is not transferable. THIS WARRANTY DOES NOT COVER normal wear and tear (including, without limitation, brake pad wear), or defects or failures that are related in any way to improper installation or follow-up maintenance, accident, abuse or neglect (including, without limitation, thread damage). Since Avid has no control over the product's final use, Avid also does not warrant the suitability of the product for specific riders and/or uses. IN NO EVENT SHALL AVID BE RESPONSIBLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES, WHETHER BASED ON CONTRACT, WARRANTY, NEGLIGENCE, OR STRICT OR PRODUCTS LIABILITY, INCLUDING WITHOUT LIMITATION, PERSONAL INJURY DAMAGES, PROPERTY DAMAGE OR ECONOMIC LOSSES. Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not apply to you. ALL IMPLIED WARRANTIES, INCLUDING ANY WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE, ARE EXPRESSLY LIMITED TO THE ONE (1) YEAR DURATION OF THIS WARRANTY. Some states do not allow limitations on how long an implied warranty lasts, so the above limitation may not apply to you. Claims under this warranty may be initiated with any Avid dealer. [. . . ] The use of any other noodle or boot could cause brake failure and lead to serious injury. Brake pad condition plays an important role in the performance of brakes, check them before every ride. If you have any question about their condition, consult your bicycle dealer or replace them. 3mm 4mm 2. [. . . ]