User manual ESCALADE SPORTS 2L-6973-01

[. . . ] ChildLife Inc. Escalade Sports® P. O. Box 889 Evansville, IN 47706 Toll Free Fax E-mail Home Page (800) GO-SWING or (800) 467-9464 (866) 873-3537 childlifecs@escaladesports. com www. childlife. com OWNER'S MANUAL Safety Instructions Maintenance Instructions Assembly Instructions This product is for residential use only. It is not intended for use in places of public assembly such as schools, parks, condominiums, churches and temples, and child care centers. WARNING! Please follow all these Safety, Maintenance, and Assembly Instructions. Failure to do so could result in serious or fatal injury. NOTE TO INSTALLER You must assemble this product in accordance with these Assembly Instructions. [. . . ] Follow the inspection and testing procedures for FRAMES AND RUNGS on previous page. Check all ropes, swing seats, and nets at the beginning of the usage season and monthly thereafter for evidence of deterioration. Immediately remove and replace any items that appear to be weak or broken. Make sure swings travel at right angles to the swing support, not into the paths of adjacent swings. Adjust the length of swing ropes to straighten the line of travel. MOVEMENT OF SWING FRAMES Some swaying of the equipment near the top is normal and to be expected. You may hear "creaking" noises as the children swing. This is also normal, particularly when the equipment is new. If Base Pieces lift off the ground, this indicates that your stakes have loosened. Reinstall or replace them before allowing further use of the equipment. ADDITIONAL ITEMS Any additional items you may have purchased and installed should be maintained in accordance with the instruction manuals provided with those items. REFINISHING Sun and moisture are the enemies of all wood, paint, and stain. Check twice each year for weather cracks in ladder rungs or wooden frame parts and fill with exterior grade crack filler. This will prevent moisture from further penetrating the wood. Look carefully for cracks in exposed end grain. If you need to touch up the painted portions of your equipment, order ChildLife Enamel (available in 4-oz and quart sizes) from your point of purchase. Reseal Ladder Rungs once a year with a non-toxic wood preservative. You can order ChildLife Clear Wood Sealer (available in quarts) from your point of purchase. Do not use glossy paint or varnish on rungs, as this will make them slippery. LAWN MAINTENANCE Do not use line trimmers or "weed eaters" around your play equipment. The line will remove both paint and wood from uprights and base pieces. Any damage resulting from this type of abuse is not covered under our limited warranty. 6 Sandcastle and Fireman's Gym combination play system ASSEMBLY INSTRUCTIONS WARNING! You must assemble this product as instructed. Do not allow children to play on equipment that has not been properly assembled. If you have any questions about the assembly of your purchase, contact ChildLife Inc. at (800) 467-9464. 1 Read these instructions in their entirety before you begin. This will help ensure an easy and safe installation. PREPARE FOR THE INSTALLATION Because of the modular nature of our product line, these instructions may be used for more than one play system configuration; know which configuration you are assembling and follow the instructions closely. 2 INVENTORY YOUR BOXES If you purchased your play system directly from ChildLife Inc. , locate the Packing List sealed in a clear plastic envelope attached to the Red Box. [. . . ] Playground equipment should never be placed on hard surfaces such as concrete or asphalt and while grass may appear to be acceptable it may quickly turn to hard packed earth in areas of high traffic. Shredded bark mulch, wood chips, fine sand or fine gravel are considered to be acceptable shock absorbing surfaces when installed and maintained at a sufficient depth under and around playground equipment. The following table lists the maximum height from which a child would not be expected to sustain a life-threatening head injury in a fall FALL HEIGHT IN FEET FROM WHICH A LIFE THREATENING HEAD INJURY WOULD NOT BE EXPECTED TYPE OF MATERIAL 6" DEPTH 9" DEPTH 12" DEPTH Double Shredded Bark Mulch Wood Chips Fine Sand Fine Gravel 6' 6' 5' 6' 10' 7' 5' 7' 11' 12' 9' 10' 1This information has been extracted from the CPSC publications "Playground Surfacing--Technical Information Guide" and "Handbook for Public Playground Safety. " Copies of these reports can be obtained by sending a postcard to the Office of Public Affairs, U. S. Consumer Product Safety Commission, Washington, D. C. [. . . ]