User manual HATCO TQM-0301

[. . . ] TOAST-QWIK TQ Series Installation & Operating Manual I&W #07. 05. 009. 00 ® Electric Conveyor Toasters This manual contains important safety information concerning the maintenance, use and operation of this product. Failure to follow the instructions contained in this manual may result in serious injury. If you're unable to understand the contents of this manual, please bring it to the attention of your supervisor. Do not operate this equipment unless you have read and understood the contents of this manual. Este manual contiene importante información sobre seguridad concerniente al mantenimiento, uso y operación de este producto. [. . . ] NOTE: Do not turn screw more than 1/8 turn at a time. Allow at least 5 minutes for temperature to stabilize. Re-install black plastic plug after adjustment is complete. Front and Rear Discharge Toast-Qwik units can be set up so product discharges at either the front or rear of the unit. For front discharge, install the toast collector pan in the front of the unit as shown in Figure 5. Pull the vane handle (rear of unit, Figure 6) until the discharge vane pivots fully in the rearward position. For rear discharge, install the toast collector pan on OPERATION TQ-300, TQ-300BA, TQ-700 & TQ-700H-S MODELS 1. Plug cabinet into an electrical outlet of the correct voltage, size and plug configuration. Turn the Selector Switch, located on the front panel, to "Toast" or "Buns. " See Figure 7. NOTE: When toasting buns, bagels or other single sided bread products, place cut side down and set Selector Switch to the "Bun" position. Turn the Speed Control to the lightest/fastest position while the unit heats up. NOTE: Allow approximately 15 minutes for a warm-up period. After warm-up period, set the Speed Control to medium position and toast two slices of bread product. Adjust the Speed Control to the desired amount of browning. Speed Control HATCO TOAST-QWIK TOAST-Qwik LIGH TE R DA OIL MOTOR PERIODICALLY OFF Selector Switch Figure 7. Control Panel ­ TQ-300, TQ-300BA, TQ-700 and TQ-700H-S Models NOTE: To toast moist products such as English muffins, rye bread or whole wheat, slow the conveyor by turning the Speed Control knob to a slower/darker setting (clockwise). RK ER TOAST BUNS 7 Form No. TQM-0301 OPERATION TQ-700H MODEL 1. Plug cabinet into an electrical outlet of the correct voltage, size and plug configuration. Turn the Selector Switch, located on the front panel, to "Toast" or "Buns. " See Figure 8. HATCO TOAST-QWIK TOAST-Qwik Selector Switch 3. Turn the Top Color Control and Bottom Color Control to the lightest/fastest position while the unit heats up. NOTE: Allow approximately 15 minutes for a warm-up period. After warm-up period, set the top and bottom Color Controls to medium position and toast two slices of bread product. Adjust the Top and Bottom Color Controls to the desired amount of browning. NOTE: To toast moist products such as English muffins, rye bread or whole wheat, slow the conveyor by turning the Speed Control knob to a slower/darker setting (clockwise). OFF EE TR TE ER R R LIGH TOAST CUT SIDE UP F AG H LI ST FAS T DA RK ER ER OW RK SL DA WE R LO TOAST BUNS STAND BY TOP COLOR BOTTOM COLOR OIL MOTOR PERIODICALLY Color Control Speed Control Figure 8. [. . . ] Oklahoma City 405-528-8883 OREGON Bressie Electric Co. Portland 503-231-7171 503-624-0890 PENNSYLVANIA Authorized Factory Service Coraopolis 412-262-2330 FAST Comm. Service Philadelphia 215-288-4800 GCS Service, Inc. Pittsburgh 412-787-1970 K & D Service Co. [. . . ]