User manual HUSQVARNA 917289620

[. . . ] 917. 289620 (YTH22V42) Owner's Manual 532 43 65-05 SAFETY RULES Safe Operation Practices for Ride-On Mowers DANGER: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. WARNING: In order to prevent accidental starting when setting up, transporting, adjusting or making repairs, always disconnect spark plug wire and place wire where it cannot contact spark plug. WARNING: Do not coast down a hill in neutral, you may lose control of the tractor. WARNING: Tow only the attachments that are recommended by and comply with specifications of the manufacturer of your tractor. [. . . ] • Keep small vent holes open. • Recharge at 6-10 amperes for 1 hour. NOTE: The original equipment battery on your tractor is maintenance free. Do not attempt to open or remove caps or covers. Adding or checking level of electrolyte is not necessary. TO CLEAN BATTERY AND TERMINALS Corrosion and dirt on the battery and terminals can cause the battery to “leak” power. • Disconnect BLACK battery cable first then RED battery cable and remove battery from tractor. • Rinse the battery with plain water and dry. • Clean terminals and battery cable ends with wire brush until bright. • Coat terminals with grease or petroleum jelly. • Reinstall battery (See “REPLACING BATTERY" in the SERVICE AND ADJUSTMENTS section of this manual). 02828 ROS "ON" POSITION ENGINE "ON" POSITION (NORMAL OPERATING) Fig. 13 15 MAINTENANCE V-BELTS Check V-belts for deterioration and wear after 100 hours of operation and replace if necessary. Replace belts if they begin to slip from wear. CLOSED AND LOCKED POSITION YELLOW CAP OIL DRAIN VALVE 02 46 3 TRANSAXLE COOLING The transmission fan and cooling fins should be kept clean to assure proper cooling. Do not attempt to clean fan or transmission while engine is running or while the transmission is hot. To prevent possible damage to seals, do not use high pressure water or steam to clean transaxle. • Inspect cooling fan to be sure fan blades are intact and clean. • Inspect cooling fins for dirt, grass clippings and other materials. To prevent damage to seals, do not use compressed air or high pressure sprayer to clean cooling fins. DRAIN TUBE • • • • • • • TRANSAXLE PUMP FLUID The transaxle was sealed at the factory and fluid maintenance is not required for the life of the transaxle. Should the transaxle ever leak or require servicing, contact your nearest authorized service center/department. ENGINE LUBRICATION Only use high quality detergent oil rated with API service classification SG-SL. Select the oil’s SAE viscosity grade according to your expected operating temperature. SAE VISCOSITY GRADES SAE 30 5W-30 F C -30 -20 -20 0 -10 30 32 0 40 10 60 20 80 30 100 40 Fig. 16 Remove yellow cap from end of drain valve and install the drain tube onto the fitting. Unlock drain valve by pushing inward and turning counterclockwise. [. . . ] 532 05 91-92 532 06 51-39 532 13 83-36 532 05 99-04 532 10 62-22 532 12 49-57 532 12 49-59 532 17 50-39 532 42 05-31 532 12 49-26 532 13 83-37 532 14 43-34 DESCRIPTION Cap Valve Tire Stem Valve Rim Front Tube Front (Service Item Only) Tire Front 15 x 6. 0-6 Fitting Grease (Front Wheel Only) Bearing Flange (Front Wheel Only) Cap Axle Blk 1 50 x 1 00 Tire R 18 x 9. 5-8 Turf Saver LT Tube Rear (Service Item Only) Rim Asm 8" Rear Sealant, Tire (10 oz. Tube) 1 2 11 3 4 7 10 5 6 9 8 NOTE: All component dimensions given in U. S. inches 1 inch = 25. 4 mm wheel_art_1-tex 42 BRIGGS ENGINE - MODEL NUMBER 407777, TYPE NUMBER 1195-B1 48 SHORT BLOCK 1036 EMISSIONS LABEL 1058 OPERATOR’S MANUAL TRACTOR - - MODEL NUMBER YTH22V42 (289620) 1329 REPLACEMENT ENGINE 1330 REPAIR MANUAL LIQUID GASKET AND THE BREATHER GASKET ARE INTERCHANGEABLE 121 CARBURETOR OVERHAUL KIT 51 163 3 358 ENGINE GASKET SET 51 46 45 1027 276 104 105 150 276A 137 672 7 987 1124 9 163 847 525 523 51A 10 15 633 1353 12 524 1095 VALVE GASKET SET 868 7 883 177 691 842 287 1022 163 20 883 868 1022 524 8 29 32 1024 850 22 1017 252 24 9 965 1013 11 404 552A 742 742 552A 552 691 616 1 2 3 718 943 28 25 415 20 750 250 12 27 27 26 16 50 51 163 51A 54 212 415 617 929 146 617 741 186 43 BRIGGS ENGINE - MODEL NUMBER 407777, TYPE NUMBER 1195-B1 5A 33 118 42 40 118A TRACTOR - - MODEL NUMBER YTH22V42 (289620) 387 405 883 187 447 447A 601 628 240 337 7 34 35 868 42 40 617 192 1022 36 1029 1100 798 703 305 601A 305A 305B 13 788 385 918 914 914 635 1023 1022 1023A 1022 5 33 42 40 431 163 34 868 883 7 968 467 445 35 1022 36 42 40 967 798 1029 1100 192 617 1040 573 865A 865 304 865B 45 209 211 216 1026A 265 188 267 1026 222 44 BRIGGS ENGINE - MODEL NUMBER 407777, TYPE NUMBER 1195-B1 125 51 163 98 51A 141 108 231 131 633 987 1342 1353 133 276 135 1124 160 947 276 418 309 117 117A 672 1127 276 1126 975 137 105 104 474 1059 851 1128 150 142 615 219 TRACTOR - - MODEL NUMBER YTH22V42 (289620) 73 668 227 95 130 333 562 278 505 212 801 789 23 510 1051 544 877 783 310 74 332 75 513 220 1005 1090 311 803 1119 635 334 1054 1070 802 697 45 BRIGGS ENGINE - MODEL NUMBER 407777, TYPE NUMBER 1195-B1 KEY NO. 1 2 3 4 5 5A 7 8 9 10 11 12 13 15 16 20 22 23 24 25 26 27 28 29 32 33 34 35 36 40 42 45 46 48 50 51 51A 53 54 73 74 75 95 98 104 105 108 117 117A 118 118A 121 125 130 131 133 135 137 141 PART NO. [. . . ]