User manual HUSTLER 302620

[. . . ] Hustler Super Mini Z Parts Manual ······· Hustler Turf Equipment ····· P. O. Box 7000 ··· Hesston, Kansas · 67062-2097 302620 Rev. 8/06 WARNING: The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. IMPORTANT: This engine is not equipped with a spark arrester muffler. It is a violation of California Public Resource Code Section 4442 to use or operate this engine on any forest-covered, brush-covered, or grass-covered unimproved land. [. . . ] Grease the front gauge wheel bearings per the Maintenance Schedule. Grease the four deck lift pivots, located to the side of the operator's footrest per the Maintenance Schedule. Use SAE Hour meter Figure 11-2 11-8 302620 8/06 multi-purpose grease. Grease the pump idler per the Maintenance Schedule. Grease the two deck pusher arm pivots per the Maintenance Schedule. Use SAE multi-purpose grease. Battery Electrical system The electrical system is a 12 volt, negative ground. Recommended battery size is a garden tractor BCI group U1R with 225 or better cranking AMP rating. A maintenance-free battery is recommended. Otherwise, follow battery manufacturer's maintenance, safety, storing and charging specifications. 11-3 WARNING: Battery posts, terminals, and related accessories contain lead and lead compounds, chemicals known to cause cancer and reproductive harm. WARNING: Avoid skin contact with battery acid. Always wear eye protection when checking the battery, acid can cause serious injury to skin and eyes. If contact occurs, flush area with clean water and call physician immediately. Do not allow open flame near the battery when charging. This gas is both toxic and flammable and may cause an explosion if exposed to flame. Always remove the negative ground first and replace it last. Electrolyte may overflow and damage paint, wiring or structure. When cleaning the battery, use soap and water. Be careful not to get soap and water into the battery. Use soda mixed in water to clean corrosion off the terminals. WARNING: Shorts caused by battery terminals or metal tools touching metal tractor components can cause sparks. Sparks can cause a battery gas explosion which will result in personal injury. [. . . ] 11-38 Start the leveling process on the left front of the tractor. Set the amount of threads protruding on the deck lift rod from the lift block at approximately 1". Push or pull on the deck lift foot pedal until the chain on the left front just becomes tight, making sure that the deck stays tight against the 3" block. While keeping the chain tight, tighten the nuts against the deck lift block on the height indicator rod. [. . . ]