User manual HUSTLER 333559

[. . . ] 36" & 42" Deck Parts Manual ···· P. O. Box 7000 ··· Hesston, Kansas · 67062-2097 333559 Rev. 8/06 WARNING: The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. IMPORTANT: This engine is not equipped with a spark arrester muffler. It is a violation of California Public Resource Code Section 4442 to use or operate this engine on any forest-covered, brush-covered, or grass-covered unimproved land. [. . . ] Clear away heavy build-up of grease, oil and dirt, especially in the engine and under the seat platform areas; minute dust particle are abrasive to close-tolerance engine and hydraulic assemblies. Daily inspect mower for grass clippings and wire and string tangles. The underside of the mower deck will collect a build-up of grass clippings and dirt, especially when grass is wet or has high moisture content. This build-up will harden, restricting blade and air movement and will probably show a poorer quality of cutting. Therefore it should be removed routinely. To do this it will be necessary to raise and block the deck, using jack stands or blocks, in the full up position and scrape the build-up from underneath. Some repairs require the assistance of a trained service mechanic and should not be attempted by unskilled personnel. Consult your Hustler The electrical system is a 12 volt, negative ground. Recommended battery size is a garden tractor BCI group U1R with 225 or better cranking AMP rating. A maintenance-free battery is recommended. Otherwise, follow battery manufacturer's maintenance, safety, storing and charging specifications. The battery is located under the seat platform. 9-2 WARNING: Battery posts, terminals, and related accessories contain lead and lead compounds, chemicals known to the State of California to cause cancer and reproductive harm. WARNING: Avoid skin and clothing contact with battery acid. Always wear eye protection when checking the battery, acid can cause serious injury to skin and eyes. If contact occurs, flush area with clean water and call physician immediately. Do not allow open flame near the battery when charging. This gas is both toxic and flammable and may cause an explosion if exposed to 9-6 333559_0806 Battery Fuse Figure 9-2 flame. Always remove the negative ground first and replace it last. Electrolyte may overflow and damage paint, wiring or structure. When cleaning the battery, use soap and water. Be careful not to get soap and water into the battery. [. . . ] Loosen the two nuts that hold the right rear deck lifting arm. Loosen the left rear deck leveling bracket by loosening the flange nuts. 5-14 Normal Spring Length 6. 0" 1. 50" Figure 9-25 7. Loosen the jam nut and back out the 5/16" bolt on top of the adjuster. [. . . ]