User manual HYOSUNG GV650 FI

[. . . ] WARNING This owner's manual contains important safety information. Please read it carefully. This manual should be considered a permanent part of the motorcycle and should remain with the motorcycle when resold or otherwise transferred to a new owner or operator. The manual contains important safety information and instructions which should be read carefully before operating the motorcycle. 1 FOREWORD THANK YOU for choosing Hyosung motorcycle. We at Hyosung have designed, tested and produced this motorcycle using the most modern technology available to provide you with much happy, enjoyable, safe riding. [. . . ] Use new "O" ring each time the engine oil filter element is replaced. Replace the oil filter cap and tighten the nuts securely but do not over tighten them. 37 9. Replace the drain plug and tighten it securely. This time, insert the gasket necessarily. Approximately 3, 200 of oil will be required. ENGINE COOLANT COOLANT LEVEL CAUTION Approximately 3, 000 of oil must be required when changing oil only without replacing the oil filter. CAUTION In case of the engine oil pouring excessively, the engine output being made insufficient. Operate the engine a few seconds by idling speed. Inspect the oil leakage at the oil filter cap. Confirm the oil level with the oil level lens after waiting about a minute next to stopping the engine. The oil level is located between the "Lower line(L)" and the "Upper line(F)". When below the "Lower line(L)", refill the oil between the "Lower line(L)" and the "Upper line(F)". The coolant should be kept between the "F"(FULL) and "L"(LOW) level lines in the reservoir tank at all times. Inspect the level every time before riding while the motorcycle vertically. If the coolant is found lower than the "L" level line, add properly mixed coolant in the following way : If the reservoir tank is emptied, pour the engine coolant to the reservoir tank and radiator. Remove the filler cap and add properly mixed coolant through the filler hole until it reaches the "F" line. Refer to the FUEL, ENGINE OIL AND COOLANT RECOMMENDATION section (13 page). 38 WARNING Engine coolant is harmful or fatal if swallowed or inhaled. Do not drink anti-freeze or coolant solution. Immediately contact a poison control center or a physician. Avoid inhaling mist or hot vapors ; if inhaled, remove to fresh air. If coolant gets in eyes, flush eyes with water and seek medical attention. Keep out of the reach of children and aminals. OPEN THE RADIATOR CAP Remove the right front side cover to operate the radiator cap . To disassemble the right front side cover , remove the two mounting bolts . WARNING You can be injured by scalding fluid or steam if you open the radiator cap when the engine is hot. After the engine cools, wrap a thick cloth around cap and carefully remove the cap by turning it a quarter to allow pressure to escape and then turn the cap all the way off. NOTE Adding only water will dilute the engine coolant and reduce its effectiveness. Add 50 : 50 mixture of engine coolant and water. CHANGING THE COOLANT Change the coolant every two years. NOTE About 1. 6 of coolant will be required when filling the radiator and reservoir tank. 39 RIDING TIPS STARTING THE ENGINE Necessary attempt before start the engine : 1. [. . . ] Check the engine idle speed. CAUTION When any trouble occurs, the best way is to consult your Hyosung dealer for repairs. WARNING Performing the spark test improperly can cause a high voltage electrical shock or an explosion. Avoid performing this check if you are not familiar with this procedure, or if you have a heart condition or wear a pacemaker. Keep the spark plug away from the spark plug hole during this test. WHEN KEEPING FOR LONG PERIOD 1. Supply the enough fuel in the fuel tank. [. . . ]