User manual JENN AIR JA580

[. . . ] USER'S MANUAL For Models JA460 and JA580 Gas Barbecue Grill 50001065/1201 Rev. 0 Warnings FOR YOUR SAFETY If you smell gas: · · · · Shut off gas to the appliance Extinguish any open flame Open lid If odor continues, immediately call your gas supplier or fire department. FOR YOUR SAFETY Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. · Always read and understand the WARNINGS and SAFETY INSTRUCTIONS that are contained in this Manual before attempting to use this Gas Barbecue Grill, to prevent possible bodily injury or property damage. Always keep this Manual in or near the Grill, for convenient future reference. · Page i Warnings SIGNAL WORDS : The Signal Words used in this Manual, and their intended meanings, are as follows : DANGER : Indicates that a failure to observe the safety instructions could result in death or catastrophic bodily injury. [. . . ] Close the Hood of the Grill. Flareups "Flareups" sometimes occur when food drippings fall onto the hot sear plates or burners and ignite. Some flaring is normal and desirable, as it helps impart the unique flavors associated with grilled foods. Controlling the intensity of the flare-ups is also desirable, however, in order to avoid burned or unevenly cooked foods and to prevent the possibility of an accidental fire. · WARNING : Always monitor the Grill carefully while cooking and turn the flame level down (LO), or OFF, if flareups intensify. Match Lighting the Main Burners 1. Always open the Hood completely and inspect the Grill and burners to confirm that all components are properly positioned, before lighting the main burners. WARNING : Never stand with your head directly over the Grill when preparing to light the main burners, to prevent possible bodily injury. Always confirm that all of the burner control knobs are in the OFF position before opening the gas supply. Always turn on the propane gas supply valve at the tank (1 to 2 turns) or turn on the main natural gas supply valve. Insert a lit match or a butane lighter into the match lighting hole located on the left hand side of the base, (see Fig. Turn the left Burner Control Knob to the HI position by pushing down on the knob and turning it counterclockwise. Fig. 10 Page 8 Operation Rotisserie Setup (Optional all Models) The Rotisserie assembly includes a counter-weight for large or irregular food items ; using the counterweight will reduce the strain on the motor. Lay a flat pan directly on the cooking grates to catch drippings. Large food items may require that you remove the cooking grates and place the pan on the sear plates. Insert the ends of the Rotisserie Support into the slots of the right cooking grate, so that the edge of the support is approximently 1" from the right casting, and the top groove is in line with the rotisserie spit hole in the left casting (see Fig. Engage the Motor Bracket into the Bracket guide on the inside edge of the left shelf. Engage the Rotisserie Motor in the Motor Bracket (see Fig. Adjust the retainer bushing to keep the spit in place (see Fig. Tighten the thumbscrews with small pliers. Always use the counterweight to balance the spit when cooking large or irregular food items. The Rotisserie Motor is rated to turn a maximum load of 12 lbs. WARNINGS : Never use the Rotisserie Motor in the rain, and never use it if it has become wet. · Always use a grounded three-prong outlet and a three-prong extension cord to energize the Rotisserie Motor. [. . . ] Use a small nail or toothpick to clean the burner ports (Fig. 15). Corroded burner Corrosion of a gas burner can cause the solid material between the gas ports to deteriorate, resulting in uneven burning. See your retailer for the appropriate replacement burner. Your Grill should burn with a predominantly blue flame. [. . . ]