User manual MAYTAG HRE21250PC

[. . . ] Series Twelve PC INTELLIGENT ELECTRIC WATER HEATER USER'S GUIDE Model Numbers HRE21250PC HRE21282PC FOR POTABLE WATER HEATING ONLY GAMA certification applies to all residential electric water heaters with capacities of 20 to 120 Gallons. Input rating of 12 Kw or less at a voltage no greater than 250 V. NOT SUITABLE FOR SPACE HEATING Caution: Read and Follow All Safety Rules and Operating Instructions Before First Use of This Product. Part No. 66001714 184744-000 WARNING READ THE GENERAL SAFETY SECTION BEGINNING ON INSIDE COVER AND THEN THIS ENTIRE MANUAL BEFORE INSTALLING OR OPERATING THIS WATER HEATER. Save this Manual for Future Reference. Printed in the U. S. A. [. . . ] Connector will install in one direction only as shown. WALL ANCHORS BACK OF THERMOSTAT ORANGE/WHITE THERMOSTAT CABLE BLUE BLUE/WHITE GREEN TERMINAL CONNECTOR MOUNTING SCREWS ORANGE GREEN/WHITE 30. Strip the remote thermostat cable outer insulation back 11/4 inches. Strip the ends 1/4 inch on each of the six colored wires. . 250 ORANGE/WHITE GREEN/WHITE BLUE/WHITE 33. Place thermostat over wall plate, press firmly, and thermostat will snap into place on the wall plate. ORANGE GREEN BLUE 1. 250 31. Using the terminal connector removed in Step 12, insert the six colored insulated wires in the remote thermostat cable into the numbered slots in the terminal connector and tighten each screw to secure each wire. Be sure to arrange wires in exact color sequence as shown. 6-WIRE CABLE ORANGE/WHITE ORANGE GREEN/WHITE GREEN BLUE/WHITE BLUE 34. Turn "ON" electric power to water heater. 6 54 321 TERMINAL CONNECTOR TERMINAL CONNECTOR THERMOSTAT CABLE 35. Read Temperature Regulation Warning and Temperature Settings, then proceed to Programming the Thermostat. 21 Instructions for Installation (cont'd) Installation Checklist 1. Whether or not the element conversion is made, the model rating plate must be marked. Using a hard point ink pen, check the appropriate block within the model rating plate, which is located adjacent to the lower access panel. Is the fuse or circuit breaker size correct as shown in the chart in the "Product Specifications" section?Are the wires from the circuit breaker or fuse service to the water heater's junction box on the correct wire size (gauge) as shown in the chart in the "Product Specifications" section?Is the new temperature-pressure relief valve properly installed, and piped to an adequate drain?See "Temperature-Pressure Relief Valve" in the "Instructions for Installation" section. Is the water heater completely filled with water?See "Filling the Water Heater" instructions in the "Instructions for Installation" section. See "Locating the New Water Heater" in the "Instructions for Installation" section. Are the cold and hot water lines connected to the water heater correctly?See "Water Piping" instructions in the "Instructions for Installation" section. Is there adequate clearance for maintenance around the water heater?If the programmable thermostat has been moved to a remote location, has the wiring been done correctly? [. . . ] If a replacement 3800 watt, 240 volt element is needed, order part no. If, at the time of installation, the water heater was converted to operate at 5500 watts, order part number 66001107 replacement element . (See model rating plate "If Converted" box). 6 3 2 4 5 25 9 24 23 20 21 19 18 17 13 12 11 8 14 38 7 10 15 16 1 3 22 Repair Parts List (cont'd) MAYTAG ELECTRIC WATER HEATERS MODEL NUMBERS HRE21250PC HRE21282PC 50 GALLON 80 GALLON KEY NO. # # PART DESCRIPTION Temperature-Pressure Relief Valve Nipple w/Heat Traps Pipe Insulation (2 each) Dip Tube Primary Anode Secondary Anode/Nipple w/Heat Traps Drain Valve Drain Valve Washer (17/32 x 13/64 x 1/8 thick)* T&P Insulation Element Gasket Lower Element Buss Bar Kit Lower Temperature Sensor Lower Access Panel Transformer/Relay Panel Transformer/Relay Board Panel Upper Access Panel Terminal Cover (Upper) Hi Limit w/ECO Hi Limit Bracket Upper Temperature Sensor Upper Element Element Gasket Programmable Thermostat Remote Thermostat Cable (50 ft. ) Manual MODEL NUMBERS HRE21250PC HRE21282PC NUMBERS 66001010 66001010 66001745 66001745 66001708 66001708 66001702 66001701 66001727 66001746 66001739 66001739 66001747 66001747 66001021 66001021 66001709 66001709 66001053 66001053 SEE NOTE ON PAGE 38 66001055 66001055 66001358 66001358 66001703 66001703 66001356 66001356 66001354 66001354 66001061 66001061 66001703 66001703 66001056 66001056 66001355 66001355 66001054 66001054 66001358 66001358 SEE NOTE ON PAGE 38 66001053 66001053 66001353 66001353 66001357 66001357 66001714 *Also available at most hardware stores. [. . . ]