Detailed instructions for use are in the User's Guide.
[. . . ] Operating & Maintenance Instructions
Model Series Covered in This Manual 19E400 19F400 19G400 192400 196400 197400 250400 256400 257400
Model
Type
Code
Note: General Model Series numbers noted above include many specific numbers like the ones on your engine. To get replacement parts or technical assistance in the future, write your engine Model, Type, Code and date of purchase here. 17
PRINTED IN U. S. A.
Month Day
Year
WARNING
Briggs & Stratton does not approve or authorize the use of these engines on 3-wheel All Terrain Vehicles (ATVs), motor bikes, aircraft products or vehicles intended for use in competitive events. Use of these engines in such applications could result in property damage, serious injury (including paralysis), or even death. [. . . ] After draining, torque 4 screws to 85 in-lbs. To refill, pour SAE 30 oil into oil fill hole until it runs out level check hole. Replace both oil plugs.
Note: Oil filler plug has a vent hole and must be installed on top of gear case cover.
FUEL SYSTEM AIR CLEANER
All engines have an air cleaner cartridge. In addition, some engines have a pre-cleaner.
CARTRIDGE P/N 496077 PRE-CLEANER P/N 492889 2 COVER SCREWS
WARNING
Replacement parts for fuel system (cap, hoses, tanks, filters, etc. ) must be the same as original parts, otherwise fire can occur.
REPLACE FUEL FILTER (if equipped)
PART NO. 298090 OR 5018 (WITHOUT FUEL PUMP) FUEL HOSE CLAMPS FUEL FILTER
RETAINER
268h19, 25 - page 12 (Black) Screen angle and frequency: 45. 0000, 150. 0000
ÌÌÌÌ ÌÌÌÌ ÌÌÌÌ ÌÌÌÌ ÌÌÌÌ ÌÌÌÌ ÌÌÌÌ ÌÌÌÌ ÌÌÌÌ
WARNING
[1]
Disconnect spark plug wire and keep away from spark plug. Drain fuel tank or close fuel shut-off valve before replacing fuel filter. Otherwise, fuel can leak out, creating a fire/explosion hazard.
[2]
TAB COVER SLOT BASE
12
MAINTENANCE
ENGINE AND ENGINE PARTS
We recommend that you see an authorized Briggs & Stratton Service Dealer for all maintenance and service of the engine and engine parts. Use only genuine Briggs & Stratton parts. If you perform any maintenance on the engine, first disconnect the spark plug wire from the spark plug, and disconnect the battery at the negative terminal (electric starter engines only) to prevent unintentional sparking. Unintentional sparking can result in fire or electric shock. Unintentional start-up can result in entanglement, traumatic amputation or laceration. Use only correct tools.
WARNING
WARNING
MUFFLER
• Do not strike the flywheel with a hammer or hard object because the flywheel may later shatter during operation. • Do not tamper with governor spring, links or other parts to increase engine speed. Note: On Model Series 19E400, 19F400, 19G400 engines use only spark plug, Part No. 496018.
WARNING
Replacement parts for the muffler must be the same and installed in the same position as the original parts, otherwise fire can occur.
AIR COOLING SYSTEM
We recommend cleaning the air cooling system every 100 hours.
CLEAN OUT DEBRIS AND CHAFF
If muffler is equipped with spark arrestor screen, remove screen for inspection. Replace screen if damaged or plugged.
SPARK PLUG
Use only Briggs & Stratton Spark Tester (part number 19368) to check for spark. Note: In some areas, local . 030” (0. 76 mm) law requires using resistor WIRE GAGE spark plug to suppress ignition signals. If this engine was originally equipped with resistor spark plug, use same type RESISTOR P/N 802592 for replacement. STANDARD P/N 492167
COMBUSTION DEPOSITS
We recommend that after every 100-300 hours you have an authorized Briggs & Stratton Service Dealer remove combustion deposits from the cylinder, cylinder head, top of piston, and around valves. Engine parts should be kept clean to reduce the risk of overheating and ignition of accumulated debris.
CLEAN
CLEANING DEBRIS
CAUTION: Do not use water to clean engine parts. Use a brush or dry cloth.
WARNING
Daily or before every use, clean accumulated debris from engine. Keep linkage, spring and controls clean. [. . . ] Your nearest Authorized Service Dealer is listed in the “Yellow Pages” of your telephone directory under “Engines, Gasoline” or “Gasoline Engines, ” “Lawn Mowers, ” or similar category.
Briggs & Stratton Engines Are Made Under One Or More Of The Following Patents: Design D-247, 177 (Other Patents Pending) DES. 309, 458 5, 852, 951 5, 548, 955 5, 269, 713 5, 188, 069 5, 040, 644 4, 895, 119 4, 630, 498 5, 546, 901 5, 265, 700 5, 186, 142 5, 040, 503 4, 875, 448 4, 522, 080 DES. 309, 457 5, 823, 153 5, 138, 996 5, 009, 208 4, 819, 593 4, 520, 288 DES. 308, 872 5, 819, 513 5, 503, 125 5, 243, 878 5, 765, 713 5, 501, 203 5, 235, 943 5, 105, 331 4, 996, 956 4, 719, 682 4, 453, 507 DES. [. . . ]