User manual NEX 720-0008-T

[. . . ] Nexgrill Industries, Inc. 145 Brea Canyon Road Walnut, CA 91789 ASSEMBLY & OPERATING INSTRUCTIONS FOR OUTDOOR GAS GRILL FOR MODEL 720-0008-T OUTDOOR GAS GRILL TABLE OF CONTENTS PAGE SAFETY INSTRUCTIONS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 ASSEMBLY INSTRUCTIONS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 LIGHTING INSTRUCTIONS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 OPERATING INSTRUCTIONS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 CLEANING & MAINTENANCE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 PARTS LIST. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 WARRANTY. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 READ THE FOLLOWING INSTRUCTIONS CAREFULLY AND BE SURE YOUR GRILL IS PROPERLY INSTALLED, ASSEMBLED AND CARED FOR. FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN SERIOUS BODILY INJURY AND/OR PROPERTY DAMAGE. IF YOU HAVE QUESTIONS CONCERNING ASSEMBLY OR OPERATION, CONSULT YOUR DEALER, GAS APPLIANCE SERVICE REPRESENTATIVE OR YOUR GAS COMPANY. [. . . ] Open gas supply for one second to blow any obstruction from fuel line. Turn off gas supply at 10 source and reconnect fuel line to grill. CORRECTION: Check for proper position of electrode tip. The tip of the electrode should be pointing toward the tip of the collector tube. The gap between the spark electrode and the lip of the gas collector tube should be 3/16". Adjust if necessary. With gas supply closed and all control knobs set to "OFF" check ignitor for presence of spark at electrode. In turn push control knob in fully and rotate slowly about 1¼''. turn to the left(counter-clockwise)until a click is heard; he trigger hitting the strike block should produce a blue spark at the electrode tip. If re-ignition is necessary while the gas grill is still hot, you must wait for a minimum of five minutes before commencing to re-ignite (this allows accumulated gas fumes to clear). If all check/corrections have been made and gas grill still fails to operate properly, consult your grill dealer or gas appliance service person. FLASH BACK: When fire occurs in and around the burner tubes immediately turn off gas at its source and turn the control knob(s) to "OFF". Wait until the grill has cooled, then clean burner tubes and burner ports. 2. b. Operation Instructions Burn-off: Before cooking on your gas grill for the first time, turn off the grill to get rid of any odors or foreign matter by igniting the burners, closing the lid; and operating at "HI" setting for about five minutes. You may then either set the controls to "OFF" or cook on your grill immediately by turning the control knobs to a lower setting. CAUTION: Operating grill on "HI" setting for longer than five minutes without foods may damage certain parts of your grill. DO NOT LEAVE GRILL UNATTENDED Preheating: The grill lid is to be in a closed position during the preheat time period. It is necessary to preheat the grill for a short time before cooking certain foods, depending on the type of food and the cooking temperature. Food that requires a high cooking temperature needs only a period of two to three minutes. There is no need to preheat for casseroles of other foods that require slow cooking. COOKING TEMPERATURES HIGH SETTING-USE this setting only for fast warm-up, for searing steaks and chops, and for burning food residue from the cooking grids after the cooking is over. Rarely, if ever, do you use the HIGH setting for extended cooking. MEDIUM SETTING-Use this setting for most grilling, roasting or baking, and for cooking hamburgers and vegetables. [. . . ] Customer Service /Telephone:1-800-913-8999 fax:909-598-7699. IMPORTANT: Use only factory authorized parts. The use of any part that is not factory authorized can be dangerous. IMPORTANT: Keep this assembly and operating instruction manual for convenient referral, and for replacement parts ordering. [. . . ]