User manual NILFISK FLOORTEC 550 P

[. . . ] ­ Petrol engine User's Manual (supplied with the machine) that is to be considered as integral part of this manual. Moreover, the following manuals are available: · Spare parts list (supplied with the machine). The purpose of this Manual is to provide the operator with all necessary information to use the machine properly in a safe and autonomous way. It contains information about technical characteristics, operation, machine storage, maintenance, spare parts and safety conditions. [. . . ] If the damage is evident, keep the packing and have it checked by the Parcel Service that delivered it. Call the Carrier immediately to fill in a damage claim. Please check that the following items have been supplied with the machine: ­ Sweeper manual ­ Petrol engine manual ­ Spare Parts List This sweeper has been designed and built to be used by a qualified operator to clean (by sweeping and vacuuming) smooth and solid floors in civil and industrial environments and to collect dust and light debris under safe operation conditions. Forward, backward, front, rear, left or right are intended with reference to the operator's position, that is to say on the driver's seat with the hands on the handlebar (1, Fig. Accelerator lever (adjusted by the Manufacturer: do not tamper with it nor use it to change the engine speed!Filling and engine oil level check plug 15. Dimensions Cleaning width without side broom Cleaning width, with side broom Machine length Machine width, without side broom Height when the handlebar is lowered Minimum height from ground Handlebar height, minimum/maximum Main broom size Side broom size Speed with maximum push force Maximum slope Hopper capacity Machine total weight Front wheel, steering Rear wheels, driving Sound pressure level (LpA) Petrol engine Make Model In addiction to the standard components, the machine can be equipped with the following accessories/options, according to the machine specific use: ­ main and side brooms with harder or softer bristles ­ Antistatic polyester or polyester BIA C dust filter ­ front wheel with brake pedal For further information concerning the optional accessories, contact Your Retailer. On some points of the machine there are some adhesives indicating: ­ DANGER ­ WARNING ­ CAUTION ­ NOTE While reading this Manual, the Operator must pay particular attention to these symbols. Do not cover these adhesives for any reason, in case of damage replace them immediately. Do not fill the fuel tank beyond the upper limit mark (1, Fig. NOTE For other petrol engine data/values, see User's Manual. Wiring diagram (See Figure W) FR: engine frame K1: engine on/off switch SP: engine ignition coil SW1: hood safety switch Color code RD: Red BK: Black V) in the close position (2) without lifting the hood (5, Fig. NOTE Do not use the starter lever if the engine is hot and if the air temperature is sufficiently high. Pull slowly the engine pull-starter cord (27, Fig. C) handle until a certain resistance is achieved; then pull strongly and start the engine. C) handle to go back with strength but bring it back to its position to prevent the engine from being damaged. C) engine start-up, do not pull the selector lever (3, Fig. The engine cannot be started by means of the pull-starter cord handle (27, Fig. A safety system prevents the engine from starting. NOTE The engine running, the main broom always rotates, while the side broom doesn't move if it is lifted. After about 5 seconds the engine runs, disengage the air lever (starter) (1, Fig. C), disengage the handle (10) from its retainer (11) and lower the handle (without turning it). [. . . ] Complete the cleaning by means of a compressed air perpendicular jet (3) of max. According to the filter type, observe the following cautions: ­ Paper filter (standard), do not use water or detergents to clean it; the filter can be damaged. ­ Polyester filter (optional): for a better cleaning, it is allowed to wash the filter with water and non-frothing detergents. This provides better quality cleaning but reduces the life of the filter, which will have to be replaced more frequently. [. . . ]