User manual RYOBI R10630

[. . . ] R10630 SPECIFICATIONS: Blade Diameter Blade Arbor Cutting Depth at 0° Cutting Depth at 45° No Load Speed Motor Charge Rate Charger Rating 5-1/2 in. (29 mm) 4, 200 RPM 18 Volt DC 1 Hour 120 Volts, 60 Hz, AC THANK YOU FOR BUYING A RYOBI CORDLESS CIRCULAR SAW. Your new cordless circular saw has been engineered and manufactured to Ryobi's high standard for dependability, ease of operation, and operator safety. Properly cared for, it will give you years of rugged, trouble-free performance. [. . . ] When the battery pack becomes discharged and is hot, this will cause the red light on your battery charger to flash. When battery pack cools down, red light will glow continuously indicating fast charging mode, 1 hour charge time. Once the battery pack cools down, it will recharge battery pack in fast charging mode as normal. NOTE: This situation only occurs when continuous use of your saw causes the batteries to become hot. It does not occur under normal circumstances. Refer to "CHARGING BATTERY PACK WITH CHARGER PART NUMBER 1400677" for normal recharging of batteries. If the charger does not charge your battery pack under normal circumstances, return both the battery pack and charger to your nearest Ryobi Authorized Service Center for electrical check. Page 9 OPERATION WARNING: Always remove battery pack from your saw when you are assembling parts, making adjustments, assembling or removing blades, cleaning, or when not in use. Removing battery pack will prevent accidental starting that could cause serious personal injury. TO REMOVE BATTERY PACK I Locate latches on end of battery pack and depress to release battery pack from your saw. DEPRESS LATCHES TO RELEASE BATTERY PACK 50 5 45 3 20 2 LATCHES BATTERY PACK 45 WARNING: Failure to remove battery pack from saw could result in accidental starting causing possible serious personal injury. 3 2 1 0 1 Fig. 4 TO INSTALL BATTERY PACK See Figure 4. Align raised rib inside saw with groove on battery pack. I Make sure the latches on each side of your battery pack snap in place and battery pack is secured in saw before beginning operation. SPINDLE LOCK BUTTON SPINDLE CAUTION: 2 3 0 2 2 5 505 4 WARNING: A 5-1/2 in. (140 mm) blade is the maximum blade capacity of your saw. Never use a blade that is too thick to allow outer blade washer to engage with the flats on the spindle. Larger blades will come in contact with the blade guard, while thicker blades will prevent blade screw from securing blade on spindle. Either of these situations could result in a serious accident. LOWER BLADE GUARD HANDLE I Locate latches on end of battery pack and depress to release battery pack from your saw. See Figure 4. I Remove blade wrench (5 mm hex key) from storage area. See Figure 1. I Depress spindle lock button and remove blade screw and outer blade washer. NOTE: Turn blade screw clockwise to remove. TO ASSEMBLE OR REMOVE BLADE TO ASSEMBLE BLADE: I Wipe a drop of oil onto inner blade washer and outer blade washer where they contact blade. I Remove battery pack from saw. WARNING: Failure to remove battery pack from saw could result in accidental starting causing possible serious personal injury. WARNING: If inner blade washer has been removed, replace it before placing blade on spindle. Failure to do so could cause an accident since blade will not tighten properly. Page 10 1 0 45 1 When placing battery pack in your saw, be sure raised rib inside saw aligns with groove on battery pack and latches snap in place properly. Improper assembly of battery pack can cause damage to internal components. 3 INNER BLADE WASHER BLADE BLADE OUTER SCREW BLADE WASHER Fig. 5 OPERATION I Fit saw blade inside lower blade guard and onto spindle. NOTE: The saw teeth point upward at the front of saw as shown in figure 5. I Replace outer blade washer. [. . . ] 1 Upper Blade Guard Screw . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Bumper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Bumper Screw . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Spring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]