User manual TOSHIBA RAS-10YKV-E SERVICE MANUAL

[. . . ] A00-T004 SUPPLEMENT SERVICE MANUAL AIR-CONDITIONER SPLIT TYPE RAS-10YKV-E / RAS-10YAV-E RA-88YKV-E / RAS-13YAV-E R410A PRINTED IN JAPAN, Aug. , 2000 ToMo CONTENTS 1. SPECIFICATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 2. REFRIGERANT R410A . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 3. CONSTRUCTION VIEWS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 4. [. . . ] (Use polyethylene foam as insulating material. ) · When bending a pipe, carefully do it not to crush it. Fig. Put water in the drain pan and make sure that the water is drained out of doors. When connecting extension drain hose, insulate the connecting part of extension drain hose with shield pipe. Shield pipe Fig. 9-2-9 How to install the front cabinet on the indoor unit · Install the front cabinet through the opposite order of "How to remove the front cabinet". When the panel is removed and mounted again, take the following actions: After fastening the two screws, one each at the left and right of the air outlet be sure to push the upper center Q, right end R, left end S and the lower center T of the air outlet, and confirm that no gap is left between the front cabinet and the rear plate. · If cooling (dry) operation is made without pushing the air outlet, dew can be Push Push Push deposited on the front 1 2 cabinet surface. In addition 3 a gap between the front cabinet and the rear plate 4 will become wilder, Push spoiling the apperance. 9-2-10 Drain hose Inside the room Extension drain hose Fig. 9-2-19 CAUTION Arrange the drain pipe for proper drainage from the unit. Improper drainage can result in dew-dropping. This air conditioner has the structure designed to drain water collected from dew, Wall which forms on the back of the indoor unit, to the drain pan. Drain guide Therefore, do not store the power cord and other parts at a height above the drain Space for guide. 9-2-7 1 Open the screw caps and remove the two screws securing the front cabinet. 3 Open the vertical air flow louver horizontally by hand. 4 Slightly open the lower part of the front cabinet then pull the upper part of the front cabinet toward you to remove it from the rear plate. 9-3. Installation Place · A place which provides the spaces around the outdoor unit as shown in the left diagram. · A place which can bear the weight of the outdoor unit and does not allow an increase in noise level and vibration. · A place where the operation noise and discharged air do not disturb your neighbors. · A place which is not exposed to a strong wind. · A place free of a leakage of combustible gases. · A place which does not block a passage. · When the outdoor unit is to be installed in an elevated position, be sure to secure its feet. [. . . ] 201 202 203 204 206 207 208 208 209 210 211 212 213 214 215 216 217 218 219 220 221 Part No. 43T00043 43T00044 43T80001 43T80002 43T07021 43T07020 43T08106 43T08107 43T19004 43T09035 43T09004 43T70001 43T21003 43T07001 43T44024 43T47006 43T47005 43T49007 43T19003 43T49003 43T49028 Description Front Panel Assembly Grille, Suction Air Filter (L) Air Filter (R) Screw Cap (L) Screw Cap (R) LED Panel (10YKV-E) LED Panel (13YKV-E) Accepted Signal Filter Horizontal Louver Assembly for Service Louver Assembly Drain Hose Assembly Motor, Stepping Bushing Refrigerant Cycle Assembly Pipe, Delivery Pipe, Suction Pipe, Shield Holder, Sensor Spring Plate, EVA-SEAL Location No. 222 224 225 226 227 228 229 230 231 232 233 236 237 238 239 241 242 243 244 245 246 Part No. 43T49023 43T79002 43T39002 43T39001 43T21010 43T20007 43T22002 43T39003 43T03001 43T07002 43T82001 43T69044 43T63002 43T62020 43T62002 43T62003 43T62004 43T39010 43T49024 43T01002 43T85061 Description Holder of Plate of EVA-SEAL Drain Guide Motor Band (Left) Motor Band (Right) Fan Motor Fan, Cross Flow Bearing Base, Bearing Rear Plate Pipe Holder Installation Plate Remote Controller Holder, Remote Controller Cover, E-Parts Cover, Up, Terminal Cord Clamp Shield Cover Drain Guide (UP) U Pipe Holder Mark Manual ­ 70 ­ Indoor Unit (2) RAS-10YKV-E, RAS-13YKV-E 233 230 222 221 215 211 216 217 226 229 244 232 228 231 201 202 214 210 206 245 207 243 220 224 218 219 225 227 236 241 237 212 209 208 246 213 239 203 204 242 238 Location No. [. . . ]