User manual UFREE SCOOTER GAS SCOOTER FS-G05

[. . . ] To include: helmet, shoes, protective clothing and pads. Never operate your scooter under influence of magnet, alcohol or drugs. Always ride with both hands on the handles. Proper speed is determined by terrain, visibility, operating condition, and experience. [. . . ] If there are any difficulties on start-up, open throttle a little, return oil door handle, press a little, pull up start handle, and engine started, then, and open air door adjuster. Proper riding: when start-up and climbing, accelerating slowly. Stop: press the button on the handle bar. 6 UFREE SCOOTER www. scooter-manufacturer. com C. Engine can have a start-up but stop while working. 2. See if silencer and fuel line is blocked. 2. Fuel line has precipitate (sediment), leakage or fuel filter blocked by dirt. Storage procedure To store engine, temperature should be -20 °C to 50 °C, moisture not more than 80%, good ventilation, isolated from easy-burning or erosion chemicals. If you plan not to use your scooter for a long time, please empty the fuel and start-up the engine to combust all fuel in the carburetor, and remove the fuel pipe. Engine: 2-Stroke, 1-Cylinger, Air-cooled Piston Displacement: 36cc Horse Power: 1. 2hp Maximum Speed: 30km/hr Starter System: Recoil/Throttle Ignition Method: CDI Load Capacity: l00kgs Fuel Type: Unleaded Petrol/Oil mix (ratio 25:1) Fuel Tank Volume: 1. 21itres Distance on Full Tank: <50km Wheels: Pneumatic Tyres Brakes: Disc brake 8 UFREE SCOOTER www. scooter-manufacturer. com Install handle bar Tighten handle bar Install T-bar Tighten T-bar Install the bar of saddle Tighten the bar of saddle 4 UFREE SCOOTER www. scooter-manufacturer. com 4. Adjust front brake: when stop function is not good, normally only adjust the screw, when need more adjustment, rope tightening must be loosened, adjust it to normal position, then tighten its nut. Check fuel door if flexible, check the flexibility and reliability on front and rear brake actuation, if it is not in good situation, adjust it in time. Air filling for front and rear tire should be 0. 5-0. 6 bar, too much pressure can cause non-smooth run. Tire pressure is too less, must have an effect on the speed and fuel consumption will be enlarged. Transmission parts should be checked and adjusted frequently. Filling lubricant regularly makes the transmission flexible. Check all bolts and nuts if they are loose, please tighten it if necessary. Keep body clean and away from moisture, high temperature and gas corrosive. V. Instruction for operating Manual start-up 1. Preparation: check stop switch, spark plug and fuel in-line and fuel return line if to be connected properly. Use unleaded gasoline and a good 2 cycle engine oil in the ratio of 25:1, and then filling it in fuel tank. If not mixed to proper ratio, the engine performance may decrease or damage to the engine may occur. Press the clear priming bulb underneath the carburetor until fuel can be seen in the clear plastic fuel return line. 5 UFREE SCOOTER Motor Sparkle plug www. scooter-manufacturer. com choke valve choke close choke open pull start Pull start III. [. . . ] If engine is abnormal, please have your engine repaired by expert. Check if fuel line goes smoothly, and if there is air bubble in, press small cup to pump fuel into carburetor. Check the spark plug and wiring for connection. Check fuel mix ratio, or for clogged gas filter. [. . . ]