User manual UFREE SCOOTER GAS SCOOTER FS-G10

[. . . ] Including: helmet, shoes, protective clothing and pads. 6. Never operate your scooter under influence of alcohol or drugs. 7. Always ride with both hands on the handles. Proper speed is determined by terrain, visibility, operating condition and experience. [. . . ] Check fuel line flexible; check the flexibility and reliability on front and rear brake actuation, if it is not in good situation, adjust it in time. Filling air for front and rear tire should be proper. Too much air can cause rough ride, if tire pressure is too low, it will have an effect on the speed and fuel consumption, which will decreased. Chain should be checked and adjust frequently, and lubricant so that the chain flexible. Check all bolts and nuts if they are loose, please tighten it if necessary. Keep body clean and away from moisture high temperature and gas corrosive. 3 UFREE SCOOTER www. scooter-manufacturer. com V. Preparation: check stop switch, spark plug and fuel in-line and fuel return line if connected properly. Use unleaded gasoline and good 2 cycle engine oil in the ratio of 25: 1 when filling in fuel tank. If not mixed to proper ratio, the engine performance may decrease or damage to the engine may occur. Press the clean priming bulb underneath the carburetor until fuel can be seen in the clear plastic fuel return line. Pull the starter grip briskly and return gently, engine should start within a few pulls. If there are any difficulties on start-up, open air adjustor a little, turn throttle control handle, and pull up start handle, engine start, then, open choke valve. Proper riding: after start-up accelerating slowly. Stop: press stop button on the handle bar. Check fuel level before start-up, refill fuel when needed. If fuel is not Flowing, check all bolts and nut if lightened, Check fuel for leak. Warm-up 3-5 minutes after cold start-up, then, use. Breaking-in (wear-in) is important to engine, within first 20 hours, choke must not be opened fully, after 20 hours, perform complete maintenance to engine, check air filter each 20 hours, clear spark plug and adjust its clearance 0. 6-0. 7mm each 50 hours, clear fuel tank and refill if necessary, clear carbon in combustion chamber and muffler, check spark plug if in good condition. To ensure long life of engine, please use fuel in accordance with the 4 UFREE SCOOTER www. scooter-manufacturer. com instruction. If engine is abnormal, pleases have professional people checked and repaired. [. . . ] Storage procedure To store engine, engine should be cool to touch, moisture not more 5 UFREE SCOOTER www. scooter-manufacturer. com than 80%, good ventilation, isolated from easy-burning or erosion chemicals. If you plan to not use your scooter for a long time, please empty the fuel lank and Start-up the engine to run all fuel in the carburetor, and remove the fuel pipe. Technical data: Item Engine CYD DIA¡ó stroke Parameter Single cylinder air-cooled 2 stroke 36¡ó 32(mm) Item Fuel Consumption Fuel tank volume Parameter 75m / 1 1 Qt GAL Sparkle plug Carburetor Speed idling Rotation engine Sparkle plug gap Fire mode BM6A Double films 2200 ± 2(X)rpm Counterclockwise 1. 0023 CDI Max speed Weight Min gap away from ground Load Package size Length¡ó width¡ó height I2mph 42 lbs 4 in 250 lbs 1180*330*505 (mm) 1220*350*1040 (mm) Start Fuel Pull start rope Unleaded gas High grade 2 stroke=25:l 33 c c I. H. D. /6500rpm Centrifugal Wheel Base Tire type 38 in 9inch Output Power Clutch type Width of steering handle Torque Tire pressure 18. 5 in 0. 9Nm/3800rpm 85P. S. I(except solid tire) 6 UFREE SCOOTER www. scooter-manufacturer. com Fig. 2 Install the bolts of the handlebar horizontal pipe 7 UFREE SCOOTER www. scooter-manufacturer. com Fig. [. . . ]