User manual UFREE SCOOTER POCKET BIKE PB-G07

[. . . ] (Before or refilling the fuel, stop the engine and cool it down 2 minutes or more. ) 1 UFREE SPORT SVEHICLE www. scooter-manufacturer. com '* If any gasoline spilt or smelled or any danger of explosion is felt, do not run the engine. * Do not stop the engine while choke lever is in the closed position. * Do not aimlessly adjust the revolution speed setting of the engine. * Do not check any spark while keeping the spark plug removed. [. . . ] Fasten the bolt for lock, so as to keep the front fork at the middle, (see figure 5) 6. Assemble the rear head cover, fasten the middle bolt. Assemble the front head cover, then fasten the two side bolt (see figure 7) 8. Everything is ready; you can ride it at any time. 6 UFREE SPORTS VEHICLE www. scooter-manufacturer. com Preparation before start-up 1. Check all bolts & nuts, brakes, engine etc. Refuel Use the mixture of the gasoline and the two-stroke engine oil. (see figure 8) Use a clean and special fuel glass and grasp cap to shake in more than 30 seconds. Don't use mixture oil in more than 1 month. 1:FC two-stroke engine oil 25:90#Gasoline (figure 8) 3. Check and clean the air filter The air filter must be often cleaned, or the polluted air filter will lower the output power of the engine. If the air filter is blocked by dust, use gasoline to clean the air filter, then dip in the oil, wring oil out and put the air filter back. (see figure 9) (figure 9) 7 UFREE SPORTS VEHICLE www. scooter-manufacturer. com Start-up Manual start Close the chock totally (see figure 10), If the engine is heated, the chock must be totally opened the choke door close open (figure 10) Operation and running The scooter is packed in a cardboard carton. After unpacking, Verify the smooth and perfect function of the Bowden cable throttle and both brakes. (Gas-oil mix 25:1) Failure to use the proper oil mix ratio will result in Engine damage for which you will be responsible Keep a low speed when turning otherwise it can causes losing control. The scooter is unsuitable for public road use. It does not comply with valid Safety Standards Unsafe and careless use of a scooter can result in serious injuries. The driver can minimize the potential risks by wearing the Safety Equipment. The driver must wear safety helmet, goggles, gloves, elbow pads, kneepads, and firm footwear. The scooter cannot be used on wet, icy or oily surfaces. Drive with two hands on the handlebars. 8 UFREE SPORTS VEHICLE www. scooter-manufacturer. com Stopping Stop throttle handle or pull down the switch in emergency. But in normal status, please operate as follows: 1. Reduce the gasoline engine to a lowest speed and run 3-5 minutes. Pull down the stop switch and stop the engine. Maintenance 1. [. . . ] (1) Maybe the air filter is blocked by dust. Maybe the cylinder exhaust and the muffler are blocked by the accumulated carbon. The piston, the piston rings and cylinder have been badly worn out. Maybe the fuel strainer is blocked by dust. [. . . ]