User manual VERMONT CASTINGS VM750

[. . . ] USER'S MANUAL for Models VM400, VM450, VM600 & VM750 DESIGN Gas Barbecue Grill C E RT I F I E D CE R TIFIE D 50002777 10/04 Rev. 0 En Warnings FOR YOUR SAFETY If you smell gas: · · · · Shut off gas to the appliance; Extinguish any open flame; Open lid; If odor continues, immediately call your gas supplier or fire department. FOR YOUR SAFETY Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. · Always read and understand the WARNINGS and SAFETY INSTRUCTIONS that are contained in this Manual before attempting to use this Gas Barbecue Grill, to prevent possible bodily injury or property damage. Always keep this Manual in or near the Grill, for convenient future reference. · Page i Warnings SIGNAL WORDS: The Signal Words used in this Manual, and their intended meanings, are as follows : DANGER: Indicates that a failure to observe the safety instructions could result in death or catastrophic bodily injury. WARNING: Indicates that a failure to observe the safety instructions could result in serious bodily injury. [. . . ] Turn the left Burner Control Knob to the HIGH position by pushing down on the knob and turning it counterclockwise. Fig. 10 Page 8 Operation Lighting the Rotisserie Burner (if applicable) The Rotisserie burner provides the steady, even heat required to cook poultry and roasts to self-basted perfection. TO START THE ROTISSERIE BURNER: 1. Always open the Hood completely before attempting to light the Grill. · WARNING: Never stand with your head directly over the Grill when preparing to light the Rotisserie burner, to prevent possible bodily injury. Always confirm that all of the burner control knobs are in the OFF position before opening the gas supply. Turn on the propane gas supply valve at the tank (1 to 2 turns) or turn on the main natural gas supply valve. Turn the Rotisserie Burner Control Knob to the HIGH position, by pushing down on the knob and turning it counterclockwise. The Rotisserie burner should light within five seconds. · WARNING: IF THE ROTISSERIE BURNER DOES NOT LIGHT, immediately turn the burner control knob to the OFF position, to prevent gas buildup Wait five (5) minutes for the gas to clear and then repeat the preceding starting procedure. If the burner will not light when using the Igniter, follow the match lighting instructions below. Confirm that the burner is properly lit and that the flame pattern is as desired, (see Figs. 9a, 9b & 9c, for the proper flame patterns). If the flame pattern is other than normal, consult the Troubleshooting Guide on Page 22 for corrective action. Always preheat the Grill before starting to cook on the rotisserie. MATCH LIGHTING THE ROTISSERIE BURNER: 1. Always open the Hood completely, before attempting to light the Grill. WARNING: Never stand with your head directly over the Grill when preparing to light the Rotisserie Burner, to prevent possible bodily injury. Always confirm that all of the burner control knobs are in the OFF position before opening the gas supply. Turn on the propane gas supply valve at the tank (1 to 2 turns) or turn on the main natural gas supply valve. Insert a lit match or a butane lighter into the match lighting hole located below the rotisserie screen (see Fig. Turn the Rotisserie Control Knob to the HIGH position by pushing down on the knob and turning it counterclockwise. Page 9 Rotisserie Lighting Hole Fig. 11 Operation Rotisserie Setup (if applicable) The Rotisserie burner is intended to be used for rotisserie cooking only. WARNING: Never use the main burners while using the Rotisserie burner, as that could result in igniting the drippings, or overheating your Grill. [. . . ] See your retailer for the appropriate replacement burner. Your Grill should burn with a predominantly blue flame. If the flame is mostly yellow, check the venturi tubes for obstruction and clean as shown on Page 19. If yellow flames still persist, adjust the opening on the air shutter of the venturi tube located under the front console of the Grill (Fig. [. . . ]