User manual YAMAHA FJR1300AE-2006

[. . . ] OWNER'S MANUAL FJR13AEV(C) LIT-11626-19-87 2D2-28199-1A EAU10041 INTRODUCTION EAU10080 Congratulations on your purchase of the Yamaha FJR13AEV(C). This model is the result of Yamaha's vast experience in the production of fine sporting, touring, and pacesetting racing machines. It represents the high degree of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual will give you an understanding of the operation, inspection, and basic maintenance of this motorcycle. [. . . ] 1000­1600 km (600­1000 mi) Avoid prolonged operation above 5400 r/min. Keep the engine speed out of the tachometer red zone. If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. G Always stop the engine using the main switch. When the engine stop switch has been used in an emergency, be sure to apply the front or rear brake while the main switch is still on, as the clutch automatically disengages a few seconds after the engine is turned off, and the rear wheel will move freely. Since the engine and exhaust system can become very hot, park in a place where pedestrians or children are not likely to touch them. 5-4 OPERATION AND IMPORTANT RIDING POINTS G Do not park on a slope or on soft ground, otherwise the vehicle may overturn. ECA10380 CAUTION: Never park in an area where there are fire hazards such as grass or other flammable materials. 5 5-5 PERIODIC MAINTENANCE AND MINOR REPAIR EAU17231 EAU17301 EAU17350 PERIODIC MAINTENANCE Safety is an obligation of the owner. Periodic inspection, adjustment and lubrication will keep your vehicle in the safest and most efficient condition possible. The most important points of motorcycle inspection, adjustment, and lubrication are explained on the following pages. Maintenance, replacement, or repair of the emission control devices and systems may be performed by any repair establishment or individual that is certified (if applicable). 6 EWA10320 Owner's tool kit WARNING If you are not familiar with maintenance work, have a Yamaha dealer do it for you. PROPER PERIODIC MAINTENANCE OF YOUR VEHICLE IS IMPORTANT IN ORDER TO ENJOY LONG, PLEASURABLE SERVICE. ESPECIALLY IMPORTANT ARE THE MAINTENANCE SERVICES RELATED TO EMISSIONS CONTROL. THESE CONTROLS NOT ONLY FUNCTION TO ENSURE CLEANER AIR, BUT ARE ALSO VITAL TO PROPER ENGINE OPERATION AND MAXIMUM PERFORMANCE. IN THE FOLLOWING PERIODIC MAINTENANCE CHARTS, THE SERVICES RELATED TO EMISSIONS CONTROL ARE GROUPED SEPARATELY. THESE SERVICES REQUIRE SPECIALIZED DATA, KNOWLEDGE, AND EQUIPMENT. YAMAHA DEALERS ARE TRAINED AND EQUIPPED TO PERFORM THESE PARTICULAR SERVICES. 1. Owner's tool kit The owner's tool kit is located under the rider seat. (See page 3-16. ) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and minor repairs. However, additional tools such as a torque wrench may be necessary to perform certain maintenance work correctly. NOTE: If you do not have the tools or experience required for a particular job, have a Yamaha dealer perform it for you. 6-1 PERIODIC MAINTENANCE AND MINOR REPAIR EWA10340 WARNING Modifications not approved by Yamaha may cause loss of performance, excessive emissions, and render the vehicle unsafe for use. Consult a Yamaha dealer before attempting any changes. 6 6-2 PERIODIC MAINTENANCE AND MINOR REPAIR EAU17600 Periodic maintenance chart for the emission control system INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 1* Fuel line · Check fuel hoses for cracks or damage. · Replace every 8000 mi (13000 km) or 12 months. · Check and adjust valve clearance when engine is cold. · Check breather hose for cracks or damage. [. . . ] 3-11 Steering, checking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-28 Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-3 Storage compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-20 Swingarm pivots, lubricating. . . . . . . . . . . . . . . . . [. . . ]