User manual YAMAHA FZ1-2008

[. . . ] OWNER'S MANUAL FZS10X FZS10XC LIT-11626-21-51 3C3-28199-12 EAU10041 INTRODUCTION EAU10080 Congratulations on your purchase of the Yamaha FZS10X/FZS10XC. This model is the result of Yamaha's vast experience in the production of fine sporting, touring, and pacesetting racing machines. It represents the high degree of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual will give you an understanding of the operation, inspection, and basic maintenance of this motorcycle. [. . . ] If the engine oil is below the minimum level mark, add sufficient oil of the recommended type to raise it to the correct level. To change the engine oil (with or without oil filter cartridge replacement) 1. Start the engine, warm it up for several minutes, and then turn it off. NOTE: Skip steps 4­6 if the oil filter cartridge is not being replaced. Remove the oil filter cartridge with an oil filter wrench. 6-12 PERIODIC MAINTENANCE AND MINOR REPAIR Recommended engine oil: See page 8-1. Oil quantity: Without oil filter cartridge replacement: 2. 90 L (3. 07 US qt) (2. 55 Imp. qt) With oil filter cartridge replacement: 3. 10 L (3. 28 US qt) (2. 73 Imp. qt) 1. Torque wrench NOTE: Make sure that the O-ring is properly seated. Install the new oil filter cartridge with an oil filter wrench, and then tighten it to the specified torque with a torque wrench. Tightening torque: Oil filter cartridge: 17 Nm (1. 7 m·kgf, 12 ft·lbf) NOTE: Be sure to wipe off spilled oil on any parts after the engine and exhaust system have cooled down. ECA11620 CAUTION: 7. Install the engine oil drain bolt, and then tighten it to the specified torque. Tightening torque: Engine oil drain bolt: 43 Nm (4. 3 m·kgf, 31 ft·lbf) G 8. Add the specified amount of the recommended engine oil, and then install and tighten the oil filler cap. G In order to prevent clutch slippage (since the engine oil also lubricates the clutch), do not mix any chemical additives. Do not use oils with a diesel specification of "CD" or oils of a higher quality than specified. In addition, do not use oils labeled "ENERGY CONSERVING II" or higher. Make sure that no foreign material enters the crankcase. 6 6-13 PERIODIC MAINTENANCE AND MINOR REPAIR 1 10. Turn the engine off, and then check the oil level and correct it if necessary. EAU20070 Coolant The coolant level should be checked before each ride. In addition, the coolant must be changed at the intervals specified in the periodic maintenance and lubrication chart. EAU40041 2 1. "ENERGY CONSERVING II" To check the coolant level 1. NOTE: G The coolant level must be checked on a cold engine since the level varies with engine temperature. G Make sure that the vehicle is positioned straight up when checking the coolant level. A slight tilt to the side can result in an incorrect reading. Check the coolant level in the coolant reservoir. NOTE: The coolant should be between the minimum and maximum level marks. 6 9. Start the engine, and then let it idle for several minutes while checking it for oil leakage. If oil is leaking, immediately turn the engine off and check for the cause. [. . . ] 6-26 M Main switch/steering lock . . . . . . . . . . . . . . . . . . . . . . . . 3-1 Maintenance and lubrication, periodic. . . . . 6-4 Maintenance, emission control system. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-3 Maintenance, periodic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-1 Maintenance record . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-5 Matte color, caution. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1 Model label. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-2 Multi-function meter unit. . . . . . . . . . . . . . . . . . . . . . . . . . 3-4 T Tail/brake light bulb, replacing . . . . . . . . . . . . . . 6-36 Throttle cable free play, checking . . . . . . . . . 6-18 Throttle grip and cable, checking and lubricating . . . . . . . . . . . . . . . . . . . . . 6-28 Tires. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]