User manual YAMAHA FZ1-N-2006

[. . . ] OWNER'S MANUAL FZ1-N 2D1-28199-E0 EAU26942 DECLARATION of CONFORMITY We Company: MORIC CO. , LTD. Address: 1450-6 Mori Mori-Machi Shuchi-gun Shizuoka 437-0292 Japan Hereby declare that the product: Kind of equipment: IMMOBILIZER Type-designation: 5SL-00 is in compliance with following norm(s) or documents: R&TTE Directive(1999/5/EC) EN300 330-2 v1. 1. 1(2001-6), EN60950(2000) Two or Three-Wheel Motor Vehicles Directive(97/24/EC: Chapter 8, EMC) Place of issue: Shizuoka, Japan Date of issue: 1 Aug. Contents To change contact person and integrate type-designation. 2005 General manager of quality assurance div. [. . . ] ITEM CHECK OR MAINTENANCE JOB 1 24 * Cooling system 25 * 26 Front and rear brake switches Moving parts and cables Throttle grip housing and cable · Check coolant level and vehicle for coolant leakage. · Adjust the throttle cable free play if necessary. · Lubricate the throttle grip housing and cable. · Check the air cut-off valve, reed valve, and hose for damage. · Replace the entire air induction system if necessary. · Check the screw clamp for looseness. 10 20 30 40 ANNUAL CHECK Every 3 years 27 * 28 * Air induction system Muffler and exhaust pipe Lights, signals and switches 29 * 30 * 6 EAU18680 NOTE: G Air filter · This model's air filter is equipped with a disposable oil-coated paper element, which must not be cleaned with compressed air to avoid damaging it. · The air filter element needs to be replaced more frequently when riding in unusually wet or dusty areas. G Hydraulic brake service · Regularly check and, if necessary, correct the brake fluid level. 6-4 PERIODIC MAINTENANCE AND MINOR REPAIR · Every two years replace the internal components of the brake master cylinders and calipers, and change the brake fluid. · Replace the brake hoses every four years and if cracked or damaged. 6 6-5 PERIODIC MAINTENANCE AND MINOR REPAIR EAU18751 EAU19651 Removing and installing the panel The panel shown needs to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time the panel needs to be removed and installed. 1. Screw Checking the spark plugs The spark plugs are important engine components, which should be checked periodically, preferably by a Yamaha dealer. Since heat and deposits will cause any spark plug to slowly erode, they should be removed and checked in accordance with the periodic maintenance and lubrication chart. In addition, the condition of the spark plugs can reveal the condition of the engine. The porcelain insulator around the center electrode of each spark plug should be a medium-to-light tan (the ideal color when the vehicle is ridden normally), and all spark plugs installed in the engine should have the same color. If any spark plug shows a distinctly different color, the engine could be defective. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. If a spark plug shows signs of electrode erosion and excessive carbon or other deposits, it should be replaced. Specified spark plug: NGK/CR9EK 6-6 To install the panel Place the panel in the original position, and then install the screw. 6 1. Panel A EAU19272 Panel A To remove the panel Remove the screw, and then pull outward on the areas shown. PERIODIC MAINTENANCE AND MINOR REPAIR Before installing a spark plug, the spark plug gap should be measured with a wire thickness gauge and, if necessary, adjusted to specification. EAU19902 NOTE: If a torque wrench is not available when installing a spark plug, a good estimate of the correct torque is 1/4­1/2 turn past finger tight. However, the spark plug should be tightened to the specified torque as soon as possible. ECA10840 Engine oil and oil filter cartridge The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter cartridge replaced at the intervals specified in the periodic maintenance and lubrication chart. [. . . ] 6-14 Engine oil and oil filter cartridge. . . . . . . . . . . . . . 6-7 Engine stop switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-12 Engine trouble warning light. . . . . . . . . . . . . . . . . . . . 3-6 EXUP system. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]