User manual YAMAHA FZS600-2000

[. . . ] OWNER'S MANUAL FZS600 FZS600SP 5DM-28199-E3 EAU00001 INTRODUCTION Welcome to the Yamaha world of motorcycling!As the owner of a FZS600/FZS600SP you are benefiting from Yamaha's vast experi, ence in and newest technology for the design and the manufacture of high-quality products, which have earned Yamaha a reputation for dependability. Please take the time to read this manual thoroughly, so as to enjoy all your FZS600/ FZS600SP's advantages. The owner's manual does not only instruct you in how to operate, inspect and maintain your motorcycle, but also in how to safeguard yourself and others from trouble and injury. [. . . ] It should be cleaned more frequently if you are riding in unusually wet or dusty areas. (See page 3-14 for seat removal and installation procedures. ) 2. (Refer to "Changing the coolant" for details on how to remove the fuel tank. ) EW000071 18. Install the hose to the fuel cock, turn the fuel cock to "ON" and temporarily place back the fuel tank. Stop the engine, lift the fuel tank slightly upward and recheck the coolant level in the radiator. If it is low, add more coolant until it reaches the top of the radiator. Fill the reservoir tank with coolant up to the maximum level. Install the radiator cap and reservoir tank cap. NOTE: If any leakage is found, ask a Yamaha dealer to inspect the cooling system. @ @ @ WARNING Support the fuel tank carefully during this procedure. q Do not tilt the fuel tank too much or pull it too hard because the fuel hose connections may become loose causing fuel leakage. q @ 22. (See pages 6-5 and 6-6 for panel removal and installation procedures. ) 6-15 PERIODIC MAINTENANCE AND MINOR REPAIR 1. Remove the rubber cover from its holders by pushing it downward. Then pull it upward and back as shown, away from the air filter case. 5. Remove the screws holding the air filter case cover. 6 6-16 PERIODIC MAINTENANCE AND MINOR REPAIR EW000072 @ 1. Pull out the air filter element. 6 7. Tap the air filter element lightly to remove most of the dust and dirt. Blow out the remaining dirt with compressed air from the mesh side of the air filter element. Install by reversing the removal procedure. EC000085 WARNING Before reinstallation, make sure that the fuel hoses are not damaged at all. If any damage is found, it may result in a fuel leak, so do not start the engine. q Always make sure that the fuel hoses are properly connected, in place, and not pinched. q @ @ CAUTION: q Make sure the air filter is properly seated in the filter case. q The engine should never be run without the air filter installed. [. . . ] 3-11 Rear brake pedal height check . . . . . . . . . . . . . . 6-23 Rear shock absorber adjustment . . . . . . . . . . . 3-17 Rear suspension lubrication. . . . . . . . . . . . . . . . . . . 6-30 Rear wheel installation. . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]