User manual YAMAHA FZS600-2002

[. . . ] OWNER'S MANUAL FZS600 5RT-28199-E0 EAU03338 INTRODUCTION Welcome to the Yamaha world of motorcycling!As the owner of an FZS600, you are benefiting from Yamaha's vast experience and newest technology regarding the design and manufacture of high-quality products, which have earned Yamaha a reputation for dependability. Please take the time to read this manual thoroughly, so as to enjoy all advantages of your FZS600. The owner's manual does not only instruct you in how to operate, inspect and maintain your motorcycle, but also in how to safeguard yourself and others from trouble and injury. [. . . ] Remove the water pump drain bolt to drain the water pump housing. Make a guide using paper or cardboard or some other type of material, hold it under the coolant drain hole, and then remove the radiator cap to drain the remaining coolant. WARNING Never attempt to remove the radiator cap when the engine is hot. @ @ 6 11. Disconnect the radiator overflow hose from the top of the radiator. 6-14 PERIODIC MAINTENANCE AND MINOR REPAIR NOTE: Check the washer for damage and replace it if necessary. @ @ Tightening torque: Coolant drain bolt: 10 Nm (1, 0 m·kgf) 1. Pull the hose holder off the frame. 6 14. Pull the hose down and to the outside while making sure to keep the end up, and then tilt the hose downward into the container to drain the coolant reservoir. NOTE: Note the original routing of the radiator overflow hose to ensure proper installation later on. @ @ 17. Connect the radiator overflow hose and make sure that it is properly routed. Pour the recommended coolant into the radiator until it is full. Recommended antifreeze: High-quality ethylene glycol antifreeze containing corrosion inhibitors for aluminum engines Antifreeze/water mixture ratio: 1:1 Coolant quantity: Total amount: 1. 95 L Coolant reservoir capacity: 0. 61 L 15. After the coolant is completely drained, thoroughly flush the cooling system with clean tap water. Install the coolant drain bolt, and then tighten it to the specified torque. 6-15 PERIODIC MAINTENANCE AND MINOR REPAIR EC000080 EW000072 @ CAUTION: G If coolant is not available, use distilled water or soft tap water instead. Do not use hard water or salt water since it is harmful to the engine. G If water has been used instead of coolant, replace it with coolant as soon as possible, otherwise the engine may not be sufficiently cooled and the cooling system will not be protected against frost and corrosion. G If water has been added to the coolant, have a Yamaha dealer check the antifreeze content of the coolant as soon as possible, otherwise the effectiveness of the coolant will be reduced. @ WARNING G Before installing the fuel tank, make sure that the fuel hoses are not damaged. If any fuel hose is damaged, do not start the engine but have a Yamaha dealer replace the hose, otherwise fuel may leak. G Make sure that the fuel hoses are properly connected and routed, and not pinched. 22. Install the radiator cap and reservoir cap, start the engine, and then check the vehicle for coolant leakage. If coolant is leaking, have a Yamaha dealer check the cooling system. Connect the fuel level sensor coupler, connect the fuel hose to the fuel tank and fuel cock, turn the fuel cock lever to "ON", and then place the fuel tank in the original position. 20. Start the engine, let it idle for several minutes, turn it off, and then slightly lift the fuel tank to check the coolant level in the radiator. If necessary, add coolant until it reaches the top of the radiator. Pour the recommended coolant into the reservoir to the maximum level mark. 6 6-16 PERIODIC MAINTENANCE AND MINOR REPAIR EAU03559* Air filter The air filter element should be cleaned at the specified intervals. [. . . ] 7-4 Storage compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13 Suspension (rear), lubricating . . . . . . . . . . . . . . . . 6-32 Removing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-41 Wheels. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]