User manual YAMAHA MAJESTY125-2006

[. . . ] OWNER'S MANUAL YP125E YP180E 5XL-F819D-E3 INTRODUCTION EAU10110 Welcome to the Yamaha world of motorcycling!As the owner of the YP125E/YP180E, you are benefiting from Yamaha's vast experience and newest technology regarding the design and manufacture of high-quality products, which have earned Yamaha a reputation for dependability. Please take the time to read this manual thoroughly, so as to enjoy all advantages of your YP125E/YP180E. The owner's manual does not only instruct you in how to operate, inspect and maintain your scooter, but also in how to safeguard yourself and others from trouble and injury. [. . . ] · Check bearing for looseness or damage. · Check bearing play and steering for roughness. · Lubricate with lithium-soap-based grease. · Make sure that all nuts, bolts and screws are properly tightened. · Check operation and for oil leakage. · Check operation and shock absorbers for oil leakage. (See page *-*. ) · Check oil level and vehicle for oil leakage. 1 10 20 30 40 9 * Rear brake 10 * Wheels 11 * Wheel bearings 12 * Steering bearings 13 * Chassis fasteners 14 Sidestand, centerstand Whenever worn to the limit Every 24000 km 6 15 * Sidestand switch 16 * Front fork 17 * Shock absorber assemblies 18 * Carburetor 19 Engine oil When the oil change indicator light comes on (every 3000 km) Every 3000 km Every 3 years Every 10000 km 20 * Engine oil strainer 21 * Cooling system 22 Final gear oil · Clean. · Check coolant level and vehicle for coolant leakage. · Check oil level and vehicle for oil leakage. 6-3 23 * V-belt PERIODIC MAINTENANCE AND MINOR REPAIR ODOMETER READING (x 1000 Km) No ANNUAL CHECK ITEM CHECK OR MAINTENANCE JOB · Check operation. · Check the screw clamp for looseness. · Adjust headlight beam. 1 10 20 30 40 24 * Front and rear brake switches 25 Moving parts and cables 26 * Muffler and exhaust pipe 27 * Lights, signals and switches 6 6-4 PERIODIC MAINTENANCE AND MINOR REPAIR EAU18711 EAU18790 EAU19210 Removing and installing cowlings and panels Cowling A Cowling B Panels 1 1 2 1 2 3 1. Cowling The cowlings and panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a cowling or panel needs to be removed and installed. To remove the cowling Remove the screws, and then take the cowling off. To install the cowling Place the cowling in the original position, and then install the screws. To remove the panel Remove the screws, and then take the panel off. To install the panel Place the panel in the original position, and then install the screws. 6-5 PERIODIC MAINTENANCE AND MINOR REPAIR EAU19620 Checking the spark plug normally). If the spark plug shows a distinctly different color, the engine could be defective. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. If the spark plug shows signs of electrode erosion and excessive carbon or other deposits, it should be replaced. Specified spark plug: CR8E (NGK) Spark plug gap: 0, 7~0, 8 mm (0, 0275in-0, 0315in) Clean the surface of the spark plug gasket and its mating surface, and then wipe off any grime from the spark plug threads. Tightening torque: Spark plug: 20 Nm 2, 0 m·kgf, 14, 46ft·lb) 1. Spark plug cap The spark plug is an important engine component, which should be checked periodically, preferably by a Yamaha dealer. Since heat and deposits will cause any spark plug to slowly erode, it should be removed and checked in accordance with the periodic maintenance and lubrication chart. [. . . ] Pour the drained fuel into the fuel tank. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from rusting and the fuel from deteriorating. Perform the following steps to protect the cylinder, piston rings, etc. Remove the spark plug cap and spark plug. [. . . ]