User manual YAMAHA MT03-2007

[. . . ] E N G L I S H EAU26942 DECLARATION of CONFORMITY We Company: MORIC CO. , LTD. Address: 1450-6 Mori Mori-Machi Shuchi-gun Shizuoka 437-0292 Japan Hereby declare that the product: Kind of equipment: IMMOBILIZER Type-designation: 5SL-00 is in compliance with following norm(s) or documents: R&TTE Directive(1999/5/EC) EN300 330-2 v1. 1. 1(2001-6), EN60950(2000) Two or Three-Wheel Motor Vehicles Directive(97/24/EC: Chapter 8, EMC) Place of issue: Shizuoka, Japan Date of issue: 1 Aug. Contents To change contact person and integrate type-designation. 2005 General manager of quality assurance div. [. . . ] · Lubricate the throttle grip housing and cable. Throttle grip housing and cable 6-4 PERIODIC MAINTENANCE AND MINOR REPAIR NO. ITEM CHECK OR MAINTENANCE JOB · Check the air cut-off valve, reed valve, and hose for damage. · Check fuel hoses for cracks or damage. · Check the screw clamp for looseness. ODOMETER READING (x 1, 000 km) 1 10 20 30 40 ANNUAL CHECK 28 Air induction system Muffler and exhaust pipe Lights, signals and switches 1 2 29 30 3 4 EAU18670 5 6 7 8 9 10 NOTE: G The air filter needs more frequent service if you are riding in unusually wet or dusty areas. G Hydraulic brake service G Regularly check and, if necessary, correct the brake fluid level. G Every two years replace the internal components of the brake master cylinders and calipers, and change the brake fluid. G Replace the brake hoses every four years and if cracked or damaged. 6-5 PERIODIC MAINTENANCE AND MINOR REPAIR EAU18771 EAUB1290 EAU19602 Removing and installing panels 1 2 3 4 5 6 7 8 9 10 The panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a panel needs to be removed and installed. Panels A and B Checking the spark plug The spark plug is an important engine component, which is easy to check. Since heat and deposits will cause any spark plug to slowly erode, the spark plug should be removed and checked in accordance with the periodic maintenance and lubrication chart. In addition, the condition of the spark plug can reveal the condition of the engine. Unhook the panel from the hook by sliding the panel upward to release it. Insert the panel on the hook, and slide the panel downward to the original position. Remove the spark plug cap. 6-6 PERIODIC MAINTENANCE AND MINOR REPAIR 2. Remove the spark plug as shown, with the spark plug wrench included in the owner's tool kit. Check that the porcelain insulator around the center electrode of the spark plug is a medium-to-light tan (the ideal color when the vehicle is ridden normally). NOTE: If the spark plug shows a distinctly different color, the engine could be defective. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. Check the spark plug for electrode erosion and excessive carbon or other deposits, and replace it if necessary. Specified spark plug: CR7E (NGK) To install the spark plug 1. Measure the spark plug gap with a wire thickness gauge and, if necessary, adjust the gap to specification. 2. Clean the surface of the spark plug gasket and its mating surface, and then wipe off any grime from the spark plug threads. [. . . ] Remove the spark plug cap and spark plug. Pour a teaspoonful of engine oil into the spark plug bore. Install the spark plug cap onto the spark plug, and then place the spark plug on the cylinder head so that the electrodes are grounded. (This will limit sparking during the next step. ) d. [. . . ]