User manual YAMAHA RM-AV2000T

[. . . ] If you have any questions concerning the operation or maintenance of your scooter, please consult a Yamaha dealer. The design and manufacture of this Yamaha scooter fully comply with the emissions standards for clean air applicable at the 3 date of manufacture. Yamaha has met these standards without reducing the performance or economy of operation of the scooter. To maintain these high standards, it is important that you and your Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. [. . . ] Tightening torque: Spark plug: 13 Nm (1. 3 m»kgf, 9. 4 fHbf) NOTE: If a torque wrench is not available when installing a spark plug, a good estimate of the correct torque is 1/4~1/2 turn past finger tight. However, the spark plug should be tightened to the specified torque as soon as possible. Install the panel. EAUT1180 Engine oil and oil strainer The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil strainer cleaned 1 at the intervals specified in the periodic 2 maintenance and lubrication chart. NOTE Make sure that the vehicle is positioned straight up when checking the oil level. A slight tilt to the side can result in a false reading. Start the engine, warm it up for several minutes, and then turn it off. Wait a few minutes until the oil settles, and then check the oil level through the check window located at the bottom-left side of the crankcase. NOTE: The engine oil should be between the minimum and maximum level marks. 3 4 5 6 7 8 9 6-9 PERIODIC MAINTENANCE AND MINOR REPAIR 1 5. Clean the oil strainer with solvent, and then check it for damage and replace it if necessary. 1 2 3 ZAUM00** ZAUM00** 4 5 6 7 8 9 1. In addition, do not use oils labeled "ENERGY CONSERVING II" or higher. 6-11 Air filter and V-belt case air filter elements<IXE> PERIODIC MAINTENANCE AND MINOR REPAIR Tightening torque: Final transmission oil drain bolt: 23 Nm (2. 3 m»kgf, 16. 6 fHbf) 6. Add the specified amount of the recommended final transmission oil, and then install and tighten the oil filler cap. ZAUM00** EAUT1301 Air filter and V-belt case air filter elements The air filter and V-belt case air filter elements should be cleaned at the intervals specified in the periodic maintenance and lubrication chart. Clean both filter elements more frequently if you are riding in unusually wet or dusty areas. Remove the air filter case cover by removing the screw. 1. Final transmission oil filler cap Recommended final transmission oil: See page 8-1. Oil quantity: 0. 13 L (0. 14 US qt) (0. 11 Imp. qt) EWA11310 w 8 Make sure that no foreign material enters the final transmission case. 8 Make sure that no oil gets on the tire or wheel. ZAUM00** 1. Install the final transmission oil drain bolt, and then tighten it to the specified torque. 7. Check the final transmission case for oil leakage. If oil is leaking, check for the cause. ZAUM00** 1. Pull the air filter element out, and 6-12 PERIODIC MAINTENANCE AND MINOR REPAIR then blow the dirt out with compressed air as shown. ECA10480 c C 8 Make sure that the air filter element is properly seated in the air filter case. [. . . ] Each Yamaha Riva dealer is held responsible for his setup, service and warranty repair work. Is the warranty transferable to second owners?The remainder of the existing warranty can be transferred upon request. The unit has to be inspected and re-registered by an authorized Yamaha Riva dealer for the policy to remain effective. 9-8 Warranty, extended<IXE> CONSUMER INFORMATION EAU26750 YAMAHA EXTENDED SERVICE (Y. E. S. ) 1 2 3 4 5 6 7 8 9 Keep your Yamaha protected even after your warranty expires with genuine Yamaha Extended Service (Y. E. S. ). [. . . ]