User manual YAMAHA T105-2005

[. . . ] OWNER'S MANUAL 5AV-F8199-E1 EAA00100 EAA20301 T105E/SE OWNER'S MANUAL © 2003 by Yamaha Motor Co, Ltd. Manufacturing 1st edition, July 2003 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Co, Ltd. Printed in China INTRODUCTION Congratulations on your purchase of the Yamaha T105E/SE. [. . . ] With the engine stopped, wait a few minutes and then remove the oil level gauge. Wipe the oil level gauge off with a clean rag and insert it in the filler hole without screwing it in. 41 d. The oil level should be between the maximum and minimum marks. If the level is low, add sufficient oil to raise it to the proper level. Place an oil pan under the engine, and remove the oil level gauge. Remove the drain plug and drain the oil. q 1 Drain plug Tightening torque Drain plug 20 Nm (2. 0 m·kg) d. Reinstall the drain plug (make sure it is tight. ) 42 Recommended oil: See page 25 Oil quantity: Total amount: 1. 0 L Periodic oil change: 0. 8 L e. Fill engine with oil through the oil level gauge hole. EUU47700 cC 9 Do not put in any chemical additives or use oils with a grade of "CD (for Diesel engine)" or higher. Also, be sure not to use oils labeled "ENERGY CONSERVING II" or higher. Engine oil also lubricates the clutch and additives could cause clutch slippage. 9 Be sure no foreign material enters the crankcase. Start the engine and warm up for a few minutes. If oil leakage is found, stop the engine immediately, and ask a Yamaha dealer to check the cause. 43 Air filter 1. Remove the front panel and the legshield by removing the screws. Remove the air filter case fitting screws and the filter case cover. 1 Air filter case cover 2 Screw (4 pcs) 3. Remove the air filter element from its case, and clean it with solvent. After cleaning, remove the remaining solvent by squeezing the element. 1 Air filter element 44 4. Apply recommended oil to the entire surface of the filter and squeeze out the excess oil. The element should be wet but not dripping. Recommended oil: Yamalube 2 (2 stroke engine oil) or Yamalube 4 (20W40) 5. Install the element in its case. cC 9 If oil is not applied to the element, the engine damage may occur. 9 Make sure the element is properly seated in the filter case. [. . . ] Substitution of a fuse of improper rating can cause extensive electrical system damage and possibly a fire. 65 EAJ50002 Troubleshooting Although Yamaha motorcycles receive a rigid inspection before shipment from the factory, trouble may occur during operation. If your motorcycle requires any repair, bring it to a Yamaha dealer. The skilled technicians at a Yamaha dealership have the tools, experience, and know-how to properly service your motorcycle. Use only genuine Yamaha parts on your motorcycle. [. . . ]