User manual YAMAHA TDR125-2000

[. . . ] OWNER'S MANUAL TDR125 5AE-28199-E3 INTRODUCTION EAU00001 Welcome to the Yamaha world of motorcycling!As the owner of a TDR125, you are benefiting from Yamaha's vast experience in and newest technology for the design and the manufacture of high-quality products, which have earned Yamaha a reputation for dependability. Please take the time to read this manual thoroughly, so as to enjoy all your TDR125's advantages. The owner's manual does not only instruct you in how to operate, inspect and maintain your motorcycle, but also in how to safeguard yourself and others from trouble and injury. [. . . ] Recommended antifreeze: High quality ethylene glycol antifreeze containing corrosion inhibitors for aluminum engines Antifreeze and water mixing ratio: 1:1 Total amount: 1. 05 L Reservoir tank capacity: 0. 35 L 1 1 1 2 3 4 5 6 7 8 9 1. Place a container under the engine and remove the coolant drain bolt. 6. Disconnect the reservoir tank hose on the reservoir tank side and drain the coolant from the reservoir tank. After draining the coolant, thoroughly flush the cooling system with clean tap water. Replace the coolant drain bolt washer if it is damaged and tighten the coolant drain bolt to the specified torque. Tightening torque: Coolant drain bolt: 8 Nm (0. 8 m0kg) cC EC000080 Hard water or salt water is harmful to the engine. You may use distilled water if you can't get soft water. 6-12 PERIODIC MAINTENANCE AND MINOR REPAIR 11. Stop the engine and recheck the coolant level in the radiator. If it is low, add more coolant until it reaches the top of the radiator. 1 2 3 4 5 6 7 8 9 1 2 3 4 5 1 1. 5. Reservoir tank cap Stopper Stopper bolt Maximum level mark Minimum level mark 1. Bolt EAU01476* Air filter The air filter should be cleaned at the specified intervals. It should be cleaned more frequently if you are riding in unusually wet or dusty areas. (See page 6-7 for cowling removal and installation steps. ) 3. Lift the front of the fuel tank upward and position it away from the air filter case. Fill the reservoir tank with coolant up to specified level. Install the reservoir tank cap and check for coolant leakage. NOTE: If any leakage is found, ask a Yamaha dealer to inspect the cooling sytem. Install the cowling, radiator cover and the seat. 6-13 PERIODIC MAINTENANCE AND MINOR REPAIR w EW000071 2 8 Support the fuel tank carefully during this procedure. 8 Do not tilt the fuel tank too much or pull it too hard because the fuel hose connections may become loose causing fuel leakage. 2 1 1 1 2 3 1. Remove the relays and the screws holding the air filter case cover. 6. Remove the air filter element from its case and clean it with solvent. After cleaning, remove the remaining solvent by squeezing the air filter. [. . . ] (This will coat the cylinder wall with oil. ) e. Remove the spark plug cap from the spark plug, install the spark plug and then the spark plug cap. 1 2 3 4 5 6 7 8 9 cC ECA00014 8 Storing the motorcycle in a poorly ventilated room or covering it with a tarp while it is still wet will allow water and humidity to seep in and cause rust. 8 To prevent corrosion, avoid damp cellars, stables (because of the presence of ammonia) and areas where strong chemicals are stored. w EWA00003 When turning the engine over, be sure to ground the spark plug electrodes to prevent damage or injury from sparking. 7-4 MOTORCYCLE CARE AND STORAGE 6. 2 3 4 5 6 7 8 9 Lubricate all control cables and the pivoting points of all levers and pedals as well as of the sidestand/centerstand. [. . . ]