User manual YAMAHA U-MAX LIGHT DUTY GAS-G27-A-2005

[. . . ] It contains important safety information. OWNER'S/OPERATOR'S MANUAL G27A G28A LIT-19626-01-08 JU7-F8199-10 1- INTRODUCTION Congratulations on your purchase of a Yamaha utility vehicle. This manual contains information you will need for proper operation, maintenance, and care of your utility vehicle. A thorough understanding of these simple instructions will help you to obtain maximum enjoyment from your new Yamaha. If you have any questions about the operation or maintenance of your utility vehicle, please consult a Yamaha dealer. TECHNICAL SERVICE DEPT YAMAHA GOLF-CAR COMPANY G27A/G28A OWNER'S/OPERATOR'S MANUAL © 2003 by Yamaha Golf-Car Company 2nd edition All rights reserved. [. . . ] Gasohol There are two types of gasohol; gasohol containing ethanol and that containing methanol. Gasohol containing ethanol can be used if ethanol content does not exceed 10%. Gasohol containing methanol is not recommended by Yamaha because it may cause fuel system damage or vehicle performance problems. CAUTION: _ Use only unleaded gasoline. The use of leaded gasoline will cause severe damage to internal engine parts, such as the valves and piston rings, as well as to the exhaust system. _ 5-4 WARNING POTENTIAL HAZARD Improper care when refueling. WHAT CAN HAPPEN Fuel can spill, which can cause a fire and severe injury. If the fuel tank is overfilled, fuel could spill out due to heat from the engine or the sun. HOW TO AVOID THE HAZARD Do not overfill the fuel tank. Be careful not to spill fuel, especially on the engine or exhaust pipe. Be sure the fuel tank cap is closed securely. Engine oil Make sure that the engine oil is at the specified level. (See pages 8-9­8-10 for details. ) CAUTION: Make sure that no foreign material enters the crankcase. Recommended engine oil type and quantity: See page 10-3. Transmission oil Make sure the transmission oil is at the specified level. (See pages 8-17­8-18 for details. ) Recommended oil: SAE 90 gear oil 5-5 Accelerator pedal Remove the key from the main switch. Make sure that the accelerator pedal operates properly. It must operate smoothly and fully spring back when released. If the accelerator pedal does not operate properly, have a Yamaha dealer check the pedal. Steering Park on level ground. Turn the steering wheel to the right and left. Check for excessive free play, abnormal noises, or a rough feeling. If the steering does not operate properly, have a Yamaha dealer check the steering. Fittings and fasteners Always check the tightness of chassis fittings and fasteners before a ride. Take the utility vehicle to a Yamaha dealer or refer to the Service Manual for the correct tightening torques. Lights Check the headlights and taillights to make sure they are in working condition. [. . . ] To raise the beam, turn the adjusting screw in direction a. To lower the beam, turn the adjusting screw in direction b. 1. Headlight bulb holder tab (× 2) 3. Insert a new headlight bulb into the bulb holder, and then hook the headlight bulb holder tabs. [. . . ]