User manual YAMAHA U-MAX MEDIUM DUTY I GAS-G23-A-2005

[. . . ] It contains important safety information. OWNER'S/OPERATOR'S MANUAL G23A LIT-19626-01-17 JU5-F8199-10 1- INTRODUCTION Congratulations on your purchase of a Yamaha utility vehicle. This manual contains information you will need for proper operation, maintenance, and care of your utility vehicle. A thorough understanding of these simple instructions will help you to obtain maximum enjoyment from your new Yamaha. If you have any questions about the operation or maintenance of your utility vehicle, please consult a Yamaha dealer. TECHNICAL SERVICE DEPT YAMAHA GOLF-CAR COMPANY G23A OWNER'S/OPERATOR'S MANUAL © 2004 by Yamaha Golf-Car Company 2nd edition All rights reserved. [. . . ] Turn the steering wheel to the right and left. Check for excessive free play, abnormal noises, or a rough feeling. If the steering does not operate properly, have a Yamaha dealer check the steering. Fittings and fasteners Always check the tightness of chassis fittings and fasteners before a ride. Take the utility vehicle to a Yamaha dealer or refer to the Service Manual for the correct tightening torques. Lights Check the headlights and taillights to make sure they are in working condition. Repair as necessary for proper operation. Switches Check the operation of all switches. Have a Yamaha dealer repair as necessary for proper operation. 5-6 WARNING POTENTIAL HAZARD Checking operation of the accelerator pedal with the key in the main switch. WHAT CAN HAPPEN The engine can start and the vehicle can start moving when the accelerator pedal is depressed. HOW TO AVOID THE HAZARD Remove the key from the main switch before checking accelerator pedal operation. Tires Checking the tire pressure Use a tire pressure gauge to measure the tire pressure. WARNING POTENTIAL HAZARD Operating this vehicle with improper tires, or with improper or uneven tire pressure. WHAT CAN HAPPEN Use of improper tires on this vehicle, or operation of this vehicle with improper or uneven tire pressure, may cause loss of control, increasing your risk of accident. The tires listed below have been approved by Yamaha Motor Manufacturing Corporation of America for this model. Other tire combinations are not recommended. Use the same brand of tires on all four wheels. Manufacturer Front Rear Kenda or Maxxis Kenda or Maxxis Size 18 × 8. 5-8 / 4 PLY 18 × 8. 5-8 / 6 PLY NOTE: Measure the tire pressure twice and use the second reading. Dust or dirt in the gauge could cause the first reading to be incorrect. 5-7 2. The tires should be set to the recommended pressure: G Recommended tire pressure Front 150 kPa (1. 53 kgf/cm2, 21 psi) Rear 207 kPa (2. 11 kgf/cm2, 30 psi) Check and adjust tire pressures when the tires are cold. Tire pressures must be equal on both sides. Use no more than the following pressures when seating the tire beads. Front 250 kPa (2. 5 kgf/cm2, 36 psi) Rear 250 kPa (2. 5 kgf/cm2, 36 psi) Higher pressures may cause the tire to burst. Inflate the tires very slowly and carefully. Fast inflation could cause the tire to burst. Tire wear limit When the tire groove decreases to 1 mm (0. 04 in) due to wear, replace the tire. a. [. . . ] To raise the beam, turn the adjusting screw in direction a. To lower the beam, turn the adjusting screw in direction b. 1. Headlight bulb holder tab (× 2) 3. Insert a new headlight bulb into the bulb holder, and then hook the headlight bulb holder tabs. [. . . ]