User manual YAMAHA V STAR 1100 SILVERADO-2005

[. . . ] OWNER'S MANUAL XVS1100AWT(C) XVS1100ATT(C) LIT-11626-18-16 5YS-28199-11 EAU10041 INTRODUCTION EAU10080 Congratulations on your purchase of the Yamaha XVS1100AW(C)/XVS1100AT(C). This model is the result of Yamaha's vast experience in the production of fine sporting, touring, and pacesetting racing machines. It represents the high degree of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual will give you an understanding of the operation, inspection, and basic maintenance of this motorcycle. [. . . ] · Check operation and for oil leakage. · Check operation and for oil leakage. 6-5 Repack. 10 * Steering bearings Repack. 11 * Chassis fasteners Brake and clutch lever pivot shafts Brake and shift pedal pivot shafts Sidestand pivot 6 12 13 14 15 * Sidestand switch 16 * Front fork 17 * Shock absorber assembly PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 18 * 19 20 * Rear suspension link pivots Engine oil Engine oil filter element · Apply lithium-soap-based grease lightly. · Change (warm engine before draining). · Check oil level and for oil leakage. · Change at initial 600 mi (1000 km) or 1 month, and thereafter every 16000 mi (25000 km) or 24 months. · Apply Yamaha chain and cable lube or engine oil SAE 10W-30 thoroughly. · Adjust the throttle cable free play if necessary. · Lubricate the throttle grip housing and cable. 21 Final gear oil Change. Change. 6 22 * Control cables 23 * Throttle grip housing and cable * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. NOTE: From 24000 mi (37000 km) or 36 months, repeat the maintenance intervals starting from 8000 mi (13000 km) or 12 months. 6-6 PERIODIC MAINTENANCE AND MINOR REPAIR EAU17630 NOTE: G The air filter needs more frequent service if you are riding in unusually wet or dusty areas. G Hydraulic brake service · After disassembling the brake master cylinders and calipers, always change the fluid. Regularly check the brake fluid levels and fill the reservoirs as required. · Every two years replace the internal components of the brake master cylinders and calipers, and change the brake fluid. · Replace the brake hoses every four years and if cracked or damaged. 6 6-7 PERIODIC MAINTENANCE AND MINOR REPAIR EAU18751 EAU19551 Removing and installing the panel The panel shown needs to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time the panel needs to be removed and installed. 1. Bolt Checking the spark plugs The spark plugs are important engine components, which are easy to check. Since heat and deposits will cause any spark plug to slowly erode, the spark plugs should be removed and checked in accordance with the periodic maintenance and lubrication chart. In addition, the condition of the spark plugs can reveal the condition of the engine. Remove the appropriate spark plug cover (rear right or front left) by pulling it off as shown. To install the panel Place the panel in the original position, and then install the bolt. Panel A EAU19151 Panel A To remove the panel Remove the bolt, and then pull the panel off as shown. 1. Remove the spark plug cap. 6-8 PERIODIC MAINTENANCE AND MINOR REPAIR 3. Remove the spark plug as shown, with the spark plug wrench included in the owner's tool kit. [. . . ] 6-19 K Key identification number. . . . . . . . . . . . . . . . . . . . . . . . 9-1 L Labels, location of . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-5 Luggage strap holders . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13 M Main switch/steering lock . . . . . . . . . . . . . . . . . . . . . . . . 3-1 Maintenance and lubrication, periodic. . . . . 6-4 Maintenance, emission control system . . . 6-3 Maintenance, periodic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-1 Maintenance record . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-5 Model label. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-2 D Dimmer switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4 E Engine break-in . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-4 Engine oil. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-10 Engine, starting a warm. . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]