User manual YAMAHA WARRIOR-2008

[. . . ] OWNER'S MANUAL XV17PCX(C) XV17PCMX(C) LIT-11626-21-27 5PX-28199-16 EAU10041 INTRODUCTION EAU10080 Congratulations on your purchase of the Yamaha XV17PCX(C)/XV17PCMX(C). This model is the result of Yamaha's vast experience in the production of fine sporting, touring, and pacesetting racing machines. It represents the high degree of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual will give you an understanding of the operation, inspection, and basic maintenance of this motorcycle. [. . . ] Air filter case element To replace the air filter element 1. Remove the air induction system cover by removing the bolts. 1. Disconnect fuel hose A from the joint as shown. c. Disconnect fuel hose B from the joint as shown. 6 b. Remove the nuts. 6-14 PERIODIC MAINTENANCE AND MINOR REPAIR ECA11530 CAUTION: G G Place a towel or cloth under the fuel hose joints when disconnecting hoses A and B to prevent fuel from spilling onto the vehicle. Make sure that no foreign material enters the fuel hose joints when the hoses are disconnected. Remove the hoses as shown, and then remove the fuel tank by pulling it upward. 1. Remove the air filter case cover by removing the screws. 6 1. Loosen the air filter case joint clamp bolt, and then pull off the air filter case. 7. Remove the air filter element by removing the screws. 6-15 PERIODIC MAINTENANCE AND MINOR REPAIR 10. Remove the clamp from the check hose, and then remove the plug to drain any accumulated water. Place the fuel tank in the original position, and then connect fuel hose B and the hoses shown. 1. Install a new air filter element by inserting it into the air filter case, then installing the screws. ECA10480 CAUTION: G 1. 4. Air filter check hose Air filter check hose holder Clamp Air filter check hose plug 1. Hose EWA10420 6 WARNING G G Make sure that the air filter element is properly seated in the air filter case. The engine should never be operated without the air filter element installed, otherwise the piston(s) and/or cylinder(s) may become excessively worn. 9. Remove the air filter check hose from the air filter check hose holder. 11. Install the air filter case cover by installing the screws. Install the air filter case by pushing it onto the air filter case joint, and then tightening the clamp bolt. Install the air filter case by installing the bolts. Install the foam damper. 6-16 G Before installing the fuel tank, make sure that the fuel hoses are not damaged. If any fuel hose is damaged, do not start the engine but have a Yamaha dealer replace the hose, otherwise fuel may leak. [. . . ] 6-28 Tires. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-18 Tool kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-1 Transfer case oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-13 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]