User manual YAMAHA XJR1300-2004

[. . . ] OWNER'S MANUAL XJR1300 5WM-28199-E1 EAU26941 DECLARATION of CONFORMITY We Company: MORIC CO. , LTD. Address: 1450-6 Mori Mori-Machi Shuchi-gun Shizuoka 437-0292 Japan Hereby declare that the product: Kind of equipment: IMMOBILIZER Type-designation: 5SL-00, 5VS-00, 5VX-00, 3HT-00, 5UX-00, 5UX-10, 5KS-00 and 5KS-10 is in compliance with following norm(s) or documents: R&TTE Directive(1999/5/EC) EN300 330-2 v1. 1. 1(2001-6), EN60950(2000) Two or Three-Wheel Motor Vehicles Directive(97/24/EC: Chapter 8, EMC) Place of issue: Shizuoka, Japan Date of issue: Aug. 1st 2002 Kazuji Kawai representative name and signature INTRODUCTION EAU10100 Welcome to the Yamaha world of motorcycling!As the owner of the XJR1300, you are benefiting from Yamaha's vast experience and newest technology regarding the design and manufacture of high-quality products, which have earned Yamaha a reputation for dependability. [. . . ] 10 20 30 40 EAU17670 ANNUAL CHECK Front and rear brake 24 * switches 25 Moving parts and cables Throttle grip housing and cable Muffler and exhaust pipe Lights, signals and switches 26 * 27 * 28 * 6 NOTE: G The air filter needs more frequent service if you are riding in unusually wet or dusty areas. G Hydraulic brake and clutch service · Regularly check and, if necessary, correct the brake and clutch fluid levels. · Every two years replace the internal components of the brake master cylinders and calipers as well as clutch master and release cylinders, and change the brake and clutch fluids. · Replace the brake and clutch hoses every four years and if cracked or damaged. 6-4 PERIODIC MAINTENANCE AND MINOR REPAIR EAU18771 Removing and installing panels The panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a panel needs to be removed and installed. 1. Place the panel in the original position, and then install the bolt. To remove the panel 1. Remove the bolt, and then pull the panel off as shown. 2. Install the seat. 6-5 PERIODIC MAINTENANCE AND MINOR REPAIR ECA12830 EAU19192 CAUTION: The area shown is not a storage compartment. Placing items here could block the air intake resulting in poor engine performance or engine damage. Panel C To remove the panel Remove the bolts, and then take the panel off. 1. Place the panel in the original position, and then install the bolt. 1. Bolt 6 EAU33020 Panel B To remove the panel 1. Remove the bolt, and then pull the panel off as shown. To install the panel Place the panel in the original position, and then install the bolts. 2. Install the seat. 6-6 PERIODIC MAINTENANCE AND MINOR REPAIR EAU19543 Checking the spark plugs The spark plugs are important engine components, which are easy to check. Since heat and deposits will cause any spark plug to slowly erode, the spark plugs should be removed and checked in accordance with the periodic maintenance and lubrication chart. In addition, the condition of the spark plugs can reveal the condition of the engine. Check each spark plug for electrode erosion and excessive carbon or other deposits, and replace it if necessary. Specified spark plug: NGK/DPR8EA-9 DENSO/X24EPR-U9 1. Spark plug wrench To check the spark plugs 1. Check that the porcelain insulator around the center electrode on each spark plug is a medium-tolight tan (the ideal color when the vehicle is ridden normally). Check that all spark plugs installed in the engine have the same color. NOTE: If any spark plug shows a distinctly different color, the engine could be defective. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. To install a spark plug 1. [. . . ] 3-8 Drive chain, lubricating . . . . . . . . . . . . . . . . . . . . . . . . . 6-21 Drive chain slack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-20 L Luggage strap holders . . . . . . . . . . . . . . . . . . . . . . . . . . 3-18 M Main switch/steering lock . . . . . . . . . . . . . . . . . . . . . . . . 3-2 Model label. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-2 Multi-function display. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-6 E Engine break-in . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-4 Engine idling speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]