User manual YAMAHA XVS125-2004

[. . . ] OWNER'S MANUAL XVS125 5JX-28199-E3 INTRODUCTION EAU10100 Welcome to the Yamaha world of motorcycling!As the owner of the XVS125, you are benefiting from Yamaha's vast experience and newest technology regarding the design and manufacture of high-quality products, which have earned Yamaha a reputation for dependability. Please take the time to read this manual thoroughly, so as to enjoy all advantages of your XVS125. The owner's manual does not only instruct you in how to operate, inspect and maintain your motorcycle, but also in how to safeguard yourself and others from trouble and injury. [. . . ] Tightening torque: Oil filter element cover bolt: 10 Nm (1. 0 m·kgf, 7. 2 ft·lbf) Recommended engine oil: See page 8-1. Oil quantity: With oil filter element replacement: 1. 60 L (1. 69 US qt) (1. 41 Imp. qt) Without oil filter element replacement: 1. 40 L (1. 48 US qt) (1. 23 Imp. qt) ECA11620 2 3 4 5 6 7 8 9 1(×3) NOTE: Make sure that the O-ring is properly seated. Install the engine oil drain bolt, and then tighten it to the specified torque. Tightening torque: Engine oil drain bolt: 34 Nm (3. 4 m·kgf, 24. 5 ft·lbf) 8. Add the specified amount of the recommended engine oil, and then install and tighten the oil filler cap. 1. Remove and replace the oil filter element and O-ring. 2 1 1. O-ring 6-9 CAUTION: G In order to prevent clutch slippage (since the engine oil also lubricates the clutch), do not mix any chemical additives. Do not use oils with a diesel specification of "CD" or oils of a higher quality than specified. In addition, do not use oils labeled "ENERGY CONSERVING II" or higher. G Make sure that no foreign material enters the crankcase. Start the engine, and then let it idle PERIODIC MAINTENANCE AND MINOR REPAIR for several minutes while checking it for oil leakage. If oil is leaking, immediately turn the engine off and check for the cause. Turn the engine off, and then check the oil level and correct it if necessary. EAU32401 Cleaning the air filter element The air filter element should be cleaned at the intervals specified in the periodic maintenance and lubrication chart. Clean the air filter element more frequently if you are riding in unusually wet or dusty areas. Remove the air filter case by removing the bolts and loosening the clamp screw. 1 1 1 2 3 4 5 1. Remove the air filter element by removing the screws. 1 6 7 8 9 1. Remove the air filter case cover by removing the screws. 4. Lightly tap the air filter element to remove most of the dust and dirt, and then blow the remaining dirt 6-10 PERIODIC MAINTENANCE AND MINOR REPAIR out with compressed air as shown. If the air filter element is damaged, replace it. Install the air filter case by installing the bolts, then tightening the clamp screw. EAU21280 Adjusting the carburetor The carburetor is an important part of the engine and requires very sophisticated adjustment. Therefore, most carburetor adjustments should be left to a Yamaha dealer, who has the necessary professional knowledge and experience. The adjustment described in the following section, however, may be serviced by the owner as part of routine maintenance. ECA10550 2 3 4 5 6 7 8 9 5. [. . . ] Remove the spark plug caps and spark plugs. Pour a teaspoonful of engine oil into each spark plug bore. Install the spark plug caps onto the spark plugs, and then place the spark plugs on the cylinder head so that the electrodes are grounded. (This will limit sparking during the next step. ) d. [. . . ]