User manual YAMAHA XVS1300A-2007

[. . . ] OWNER'S MANUAL XVS1300A 11C-28199-E0 EAU26943 DECLARATION of CONFORMITY We Company: MORIC CO. , LTD. Address: 1450-6 Mori Mori-Machi Shuchi-gun Shizuoka 437-0292 Japan Hereby declare that the product: Kind of equipment: IMMOBILIZER Type-designation: 5SL-00 is in compliance with following norm(s) or documents: R&TTE Directive(1999/5/EC) EN300 330-2 v1. 1. 1(2001-6), EN60950-1(2001) Two or Three-Wheel Motor Vehicles Directive(97/24/EC: Chapter 8, EMC) Place of issue: Shizuoka, Japan Date of issue: 1 Aug. Contents To change contact person and integrate type-designation. 1 Version up the norm of EN60950 to EN60950-1 2 Date 9 Jun. [. . . ] · Make sure that all nuts, bolts and screws are properly tightened. · Check operation and for oil leakage. · Check operation and shock absorber for oil leakage. · Lubricate with lithium-soap-based grease. · Check oil level and vehicle for oil leakage. Every 50000 km Every 4000 km Every 20000 km 6 17 * Sidestand switch 18 * Front fork 19 * Shock absorber assembly Rear suspension relay 20 * arm and connecting arm pivoting points 21 * Fuel injection system 22 Engine oil 6-3 PERIODIC MAINTENANCE AND MINOR REPAIR ODOMETER READING (× 1000 km) NO. ITEM Engine oil filter cartridge CHECK OR MAINTENANCE JOB 1 23 · Replace. · Check coolant level and vehicle for coolant leakage. · Adjust the throttle cable free play if necessary. · Lubricate the throttle grip housing and cable. · Check the screw clamp for looseness. 10 20 30 40 ANNUAL CHECK 24 * Cooling system 25 * 26 Front and rear brake switches Moving parts and cables Throttle grip housing and cable Muffler and exhaust pipe Lights, signals and switches Every 3 years EAU18680 27 * 28 * 29 * 6 NOTE: G Air filter · This model's air filter is equipped with a disposable oil-coated paper element, which must not be cleaned with compressed air to avoid damaging it. · The air filter element needs to be replaced more frequently when riding in unusually wet or dusty areas. G Hydraulic brake service · Regularly check and, if necessary, correct the brake fluid level. · Every two years replace the internal components of the brake master cylinders and calipers, and change the brake fluid. 6-4 PERIODIC MAINTENANCE AND MINOR REPAIR · Replace the brake hoses every four years and if cracked or damaged. 6 6-5 PERIODIC MAINTENANCE AND MINOR REPAIR EAU18771 Removing and installing panels The panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a panel needs to be removed and installed. 1. Panel C EAU19193 To install the panel Place the panel in the original position, and then install the bolts. EAU42571 Panels B and C To remove the panels Remove the bolt and the quick fastener screw from each panel, lift the panels upward enough to separate them, and then remove them as shown. Panel A To remove the panel Remove the bolts, and then take the panel off. 1. Bolt 6-6 PERIODIC MAINTENANCE AND MINOR REPAIR EAU42430 Checking the spark plugs The spark plugs are important engine components, which are easy to check. Since heat and deposits will cause any spark plug to slowly erode, the spark plugs should be removed and checked in accordance with the periodic maintenance and lubrication chart. In addition, the condition of the spark plugs can reveal the condition of the engine. Remove the appropriate spark plug cover (rear right or front left) by removing the bolts. 1. 4. Panel C Bolt Quick fastener screw Panel B 1. [. . . ] 6-11 Coolant temperature warning light. . . . . . . . . . 3-4 K Key identification number. . . . . . . . . . . . . . . . . . . . . . . . 9-1 L License plate light bulb, replacing . . . . . . . . . 6-31 D Dimmer switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-9 Drive belt slack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-21 M Main switch/steering lock . . . . . . . . . . . . . . . . . . . . . . . . 3-2 Matte color, caution. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1 Model label. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-2 Multi-function meter unit. . . . . . . . . . . . . . . . . . . . . . . . . . 3-5 E Engine break-in . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]