User manual YAMAHA XVS1300A-2008

[. . . ] OWNER'S MANUAL XVS1300A 11C-28199-E1 EAU26944 YAMAHA MOTOR ELECTRONICS CO. , LTD. 1450-6, Mori, Mori-machi, Shuchi-gun, Shizuoka-ken, 437-0292 Japan DECLARATION of CONFORMITY We Company: YAMAHA MOTOR ELECTRONICS CO. , LTD. Address: 1450-6, Mori, Mori-Machi, Shuchi-gun, Shizuoka-Ken, 437-0292 Japan Hereby declare that the product: Kind of equipment: IMMOBILIZER Type-designation: 5SL-00 is in compliance with following norm(s) or documents: R&TTE Directive(1999/5/EC) EN300 330-2 v1. 1. 1(2001-6), EN60950-1(2001) Two or Three-Wheel Motor Vehicles Directive(97/24/EC: Chapter 8, EMC) Place of issue: Shizuoka, Japan Date of issue: 1 Aug. Contents To change contact person and integrate type-designation. 1 Version up the norm of EN60950 to EN60950-1 2 To change company name 3 Date 9 Jun. [. . . ] · Lubricate with lithium-soap-based grease. · Check operation and for oil leakage. · Check operation and shock absorber for oil leakage. · Lubricate with lithium-soap-based grease. · Check oil level and vehicle for oil leakage. · Check coolant level and vehicle for coolant leakage. · Change. 21 * Sidestand switch 22 * Front fork 23 * Shock absorber assembly 6 Rear suspension relay arm and con24 * necting arm pivoting points 25 * Fuel injection system Engine oil Engine oil filter cartridge 26 27 28 * Cooling system Front and rear brake 29 * switches Every 3 years 6-4 · Check operation. PERIODIC MAINTENANCE AND MINOR REPAIR ODOMETER READING NO. ITEM CHECK OR MAINTENANCE JOB 1000 km (600 mi) 10000 km (6000 mi) 20000 km (12000 mi) 30000 km (18000 mi) 40000 km (24000 mi) ANNUAL CHECK 30 Moving parts and cables · Lubricate. · Adjust the throttle cable free play if necessary. · Lubricate the throttle grip housing and cable. · Check the screw clamp for looseness. Throttle grip hous31 * ing and cable 32 * 33 * Muffler and exhaust pipe Lights, signals and switches EAU18680 6 NOTE: G Air filter · This model's air filter is equipped with a disposable oil-coated paper element, which must not be cleaned with compressed air to avoid damaging it. · The air filter element needs to be replaced more frequently when riding in unusually wet or dusty areas. G Hydraulic brake service · Regularly check and, if necessary, correct the brake fluid level. · Every two years replace the internal components of the brake master cylinders and calipers, and change the brake fluid. · Replace the brake hoses every four years and if cracked or damaged. 6-5 PERIODIC MAINTENANCE AND MINOR REPAIR EAU18751 EAU42430 Removing and installing the panel The panel shown needs to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time the panel needs to be removed and installed. 1. Bolt Checking the spark plugs The spark plugs are important engine components, which are easy to check. Since heat and deposits will cause any spark plug to slowly erode, the spark plugs should be removed and checked in accordance with the periodic maintenance and lubrication chart. In addition, the condition of the spark plugs can reveal the condition of the engine. Remove the appropriate spark plug cover (rear right or front left) by removing the bolts. 6 1. Panel A EAU19193 To install the panel Place the panel in the original position, and then install the bolts. Panel A To remove the panel Remove the bolts, and then take the panel off. 1. [. . . ] 6-11 Coolant temperature warning light. . . . . . . . . . 3-5 K Key identification number. . . . . . . . . . . . . . . . . . . . . . . . 9-1 L License plate light bulb, replacing . . . . . . . . . 6-30 D Dimmer switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-10 Drive belt slack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-20 M Main switch/steering lock . . . . . . . . . . . . . . . . . . . . . . . . 3-2 Matte color, caution. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1 Model label. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-2 Multi-function meter unit. . . . . . . . . . . . . . . . . . . . . . . . . . 3-6 E Engine break-in . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]