User manual YAMAHA YBR 125 GLADIATOR

[. . . ] ROKE MOTOR OIL W40 (Starter Motor & Disc Brake) 4 er Engine Life r Maintenance Cost r Exhaust Smoke ces Wear and Tear OWNER'S MANUAL 5P4-F8199-E1 5P42 5P4-F8199-E1 Starter Motor & Disc Brake PRINTED IN INDIA 2Y16(OM-01)-271-08-06-E WARNING PLEASE READ THIS MANUAL CAREFULLYAND COMPLETELY BEFORE OPERATING THIS MOTORCYCLE. OWNER'S MANUAL YAMAHA MOTOR INDIA PVT. Any reprinting or unauthorised use without the written permission of YAMAHA MOTOR INDIA PVT. LIMITED is expressly prohibited. TAKE NECESSARY PRECAUTIONS DURING RUNNING-IN PERIOD. INTRODUCTION Congratulations on your purchase of the GLADIATOR . This motorcycle has been produced using the latest technology in our modern plant, to provide you a happy, enjoyable and safe riding for many thousand kilometers and years. [. . . ] It should be cleaned more frequently when riding in unusually wet or dusty areas. (See page 6-6 for removal and installation procedures. ) 2. Remove the air filter case fitting screws and the air filter case cover. Dip the Air Filter Elements in recommended oil squeeze out the excess oil. Recommended oil: YAMALUBE 20W40 Type SG 6-10 PERIODIC MAINTENANCE AND MINOR REPAIR` CAUTION : · 7. Pull the air filter elements over the frame and install the air filter in the case. Install the air filter case cover and panel Make sure the air filter is properly seated in the air filter case. The engine should never be run without the air filter installed. Excessive piston and/or cylinder wear may result. Dirty Element Air Cleaner causes excessive fuel consumption and loss of power. Clean Element Air Cleaner after every 2000 Kms. The Element Air Cleaner should be cleaned and lubricated more frequently (every 1000 kms), if Motorcycle is operated in very dusty (e. g. unpaved, dust laden roads) conditions. Carburetor adjustment The carburetor is a vital part of the engine and requires very sophisticated adjustments. Most adjustments should be left to a YAMAHA dealer who has the professional knowledge and experience to do so. However, the following may be serviced by the owner as part of routine maintenance. · · CAUTION : Do not twist Element Air Cleaner. CAUTION : The carburetor was set at the YAMAHA factory after many tests. If the settings are changed, poor engine performance and damage may result. · · NOTE : Ensure no distoration/proper positioning of felt Seal 1 , if damaged contact YAMAHA Dealer. 1 6-11 PERIODIC MAINTENANCE AND MINOR REPAIR Idle speed adjustment NOTE : A diagnostic tachometer must be used for this procedure. Start the engine and warm it up for a few minutes at approximately 1, 300 to 1, 500 r/min. Occasionally rev the engine to 4, 000 to 5, 000 r/min. The engine is warm when it quickly responds to the throttle. Throttle cable free play adjustment NOTE : b 1. Throttle stop screw 1 a Before checking the throttle cable free play, the engine idling speed should be adjusted. Adjust the throttle cable by turning the adjusting nut so that specified free play at the throttle grip is obtained. Set the idle to the specified engine speed by adjusting the throttle stop screw. [. . . ] a) c) Air Filter : d) Piston/Rings/Cylinder : e) Exhaust System f) Valve Timing : : Clean every 2000 kms as per the environment conditions. Check / Clean / Replace if necessary Check / Replace if necessary Check / Adjust every 4500 kms Check / Diagnose. 1 g) Compression pressure : greenbook. PMD 2 8/28/2006, 2:24 PM DO'S AND DON'TS FOR THE MOTORCYCLE 6 Always drive with Starter Lever in OFF position. 7 Use Starter Lever for minimum possible period (1 to 2 minutes) only to start and warm up Engine (may be required only in winter) 8 If misfiring, get your Motorcycle diagnosed & attended immediately without running even for a KM. 9 Get Motorcycle maintained regularly as per details and schedule given in Owner's Manual. [. . . ]