User manual YAMAHA YZF-600R-2004

[. . . ] OWNER'S MANUAL YZF600RS LIT-11626-17-16 5AH-28199-17 EAU10041 INTRODUCTION EAU10080 Congratulations on your purchase of the Yamaha YZF600R. This model is the result of Yamaha's vast experience in the production of fine sporting, touring, and pacesetting racing machines. It represents the high degree of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual will give you an understanding of the operation, inspection, and basic maintenance of this motorcycle. [. . . ] Apply a thin coat of engine oil to the O-ring of the new oil filter cartridge. Tightening torque: Oil filter cartridge: 17 Nm (1. 7 m·kgf, 12 ft·lbf) CAUTION: G 8. Install the engine oil drain bolt, and then tighten it to the specified torque. NOTE: Check the washer for damage and replace it if necessary. Tightening torque: Engine oil drain bolt: 43 Nm (4. 3 m·kgf, 31 ft·lbf) G In order to prevent clutch slippage (since the engine oil also lubricates the clutch), do not mix any chemical additives. Do not use oils with a diesel specification of "CD" or oils of a higher quality than specified. In addition, do not use oils labeled "ENERGY CONSERVING II" or higher. Make sure that no foreign material enters the crankcase. Add the specified amount of the recommended engine oil, and then install and tighten the oil filler cap. Recommended engine oil: See page 8-1. Oil quantity: Without oil filter cartridge replacement: 2. 60 L (2. 75 us. qt) (2. 29 Imp. qt) With oil filter cartridge replacement: 2. 90 L (3. 07 us. qt) (2. 55 Imp. qt) NOTE: Make sure that the O-ring is properly seated. Install the new oil filter cartridge with an oil filter wrench, and then tighten it to the specified torque with a torque wrench. 10. Start the engine, and then let it idle for several minutes while checking it for oil leakage. If oil is leaking, immediately turn the engine off and check for the cause. NOTE: After the engine is started, the engine oil level warning light should go off if the oil level is sufficient. 6-13 PERIODIC MAINTENANCE AND MINOR REPAIR ECA10400 EAU20070 CAUTION: If the oil level warning light flickers or remains on, immediately turn the engine off and have a Yamaha dealer check the vehicle. Turn the engine off, and then check the oil level and correct it if necessary. Install the cowling. Coolant The coolant level should be checked before each ride. In addition, the coolant must be changed at the intervals specified in the periodic maintenance and lubrication chart. EAU20141 To check the coolant level 1. Place the vehicle on a level surface and hold it in an upright position. NOTE: G The coolant level must be checked on a cold engine since the level varies with engine temperature. G Make sure that the vehicle is positioned straight up when checking the coolant level. A slight tilt to the side can result in a false reading. Check the coolant level in the coolant reservoir. NOTE: The coolant should be between the minimum and maximum level marks. 6-14 1. If the coolant is at or below the minimum level mark, open the coolant reservoir cap. [. . . ] 5-4 Engine oil and oil filter cartridge. . . . . . . . . . . . 6-11 Engine, starting a warm . . . . . . . . . . . . . . . . . . . . . . . . . . 5-3 Engine stop switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-5 T Tachometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]