User manual APRILIA ETV MILLE CAPONORD 2003

[. . . ] ETV mille Caponord use+maintenancebook aprilia part# 8104310 2001 DSULOLD VSD - Noale (VE) 6$)(7< :$51, 1*6 The following precautionary warnings are used throughout this manual in order to convey the following messages: 6DIHW\ ZDUQLQJ :KHQ \RX ILQG WKLV V\PERO RQ WKH YHKLFOH RU LQ WKH PDQXDO EH FDUHIXO WR WKH SRWHQWLDO ULVN RI SHUVRQDO LQMXU\ 1RQFRPSOLDQFH ZLWK WKH LQGLFDWLRQV JLYHQ LQ WKH PHVVDJHV SUHFHGHG E\ WKLV V\PERO PD\ UHVXOW LQ JUDYH ULVNV IRU \RXU DQG RWKHU SHRSOHV VDIHW\ DQG IRU WKH YHKLFOH 7(&+1, &$/ , 1)250$7, 21 The operations preceded by this symbol must be repeated also on the opposite side of the vehicle. If not expressly indicated otherwise, for the reassembly of the units repeat the disassembly operations in reverse order. The terms "right" and "left" are referred to the rider seated on the vehicle in the normal riding position. # First edition: february 2001 Reprint: may 2003 , QGLFDWHV D SRWHQWLDO KD]DUG ZKLFK PD\ UHVXOW LQ VHULRXV LQMXU\ RU HYHQ GHDWK :$51, 1* :$51, 1*6 35(&$87, 216 *(1(5$/ $'9, &( Before starting the engine, carefully read this manual and in particular the section "SAFE DRIVE". Your and other people's safety depends not only on your quickness of reflexes and on your agility, but also on what you know about the vehicle, on its efficiency and on your knowledge of the basic information for "SAFE DRIVE". [. . . ] In this way the components are first "loaded" and then "relieved" and the engine parts can thus cool down. Even if it is important to stress the engine components during running-in, take care not to exceed. aWARNING After the first 1000 km (625 mi), have an APRILIA Official Dealer carry out the checks indicated in the column "After running-in" of the regular service intervals chart, see p. 60 (REGULAR SERVICE INTERVALS CHART), in order to avoid hurting yourself or other people and/or damaging the vehicle. N Between the first 1000 (625 mi) and NOTE Only after the first 1500 km (937 mi) of running-in you can expect the best performance levels from the vehicle. Keep to the following indications: N Do not open the throttle completely if the speed is low, both during and after the running-in. N During the first 100 km (62 mi) put on the brakes with caution, avoiding sharp and prolonged brakings. This ensures a correct bedding-in of the pads on the brake disc. N During the first 1000 km (625 mi) never exceed 5000 rpm. 1500 km (937 mi) drive more briskly, change speed and use the maximum acceleration only for a few seconds, in order to ensure better coupling of the components; never exceed 6250 rpm (see table). N After the first 1500 km (937 mi) you can expect better performance from the engine, however, without exceeding the maximum allowed (8750 rpm). Engine maximum rpm recommended Mileage km (mi) 0 1000 (0 625) 1000 1500 (625 937) over 1500 (937) rpm 5000 6250 8750 54 use and maintenance ETV mille Caponord 3 5 aWARNING The fall or excessive inclination of the vehicle may cause the fuel to flow out of the tank. The fuel used for internal combustion engines is extremely inflammable and in particular conditions it can become explosive. A 1 2 PU SH 4 aCAUTION Do not apply the load of your weight or of the passenger's weight onto the side stand. To park the vehicle: N Choose a suitable parking area. 55 (STOPPING). 34/00). ' 0!2+). ' It is very important to choose a suitable parking area, respecting the road signs and the indications given below. aWARNING If possible, avoid stopping abruptly, slowing down suddenly and braking at the last moment. N Release the throttle grip (1) (Pos. A), aWARNING Park the vehicle on firm and flat ground, to prevent it from falling down. Neither lean the vehicle against walls, nor lay it on the ground. Make sure that the vehicle and especially its red-hot parts do not represent a danger for persons and children. Do not leave the vehicle unattended when the engine is on or the key is inserted into the ignition switch. Do not get too near the cooling fans even if they are still, since they may start moving and suck clothes edges, hair, etc. aCAUTION To stop the vehicle, use exclusively the ignition switch (4). Leave the engine stop switch (5) in position "2" and use it only in case of emergency. N Rotate the key (3) and move the ignition gradually put on the brakes and at the same time shift down in order to decrease the speed, see p. Once the speed has decreased, before stopping the vehicle: N Pull the clutch lever (2) in order to prevent the stopping of the engine. When the vehicle has come to rest: N Shift the gear lever to neutral (green switch (4) to position "1". aWARNING When getting on or off the vehicle, keep to the instructions given, see p. 44 (GETTING ON AND OFF THE VEHICLE). N Following the indications, wait until the warning light LED "/" on). N Release the clutch lever (2). N In case of a brief stop, keep at least one passenger has got off the vehicle before dismounting. use and maintenance ETV mille Caponord brake on. 55 2 PU SH PU SH 1 3 N Lock the steering, see p. 25 (STEERING LOCK) and extract the key. 0/3)4)/. ). ' 4(% 6%()#, % /. [. . . ] Dashboard lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Neutral . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Direction indicators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fuel reserve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]