User manual APRILIA GULLIVER 50 03-1999

[. . . ] use and maintenance Gulliver 50 © 1996 aprilia s. p. a. - Noale (VE) This manual is to be considered an integral part of the vehicle, which must be delivered complete with it also in case of resale. reserves the right to modify its models at any time, without prejudice to the main characteristics here described. All rights as to electronic storage, reproduction and total or partial adaptation, with any means, are reserved for all Countries. [. . . ] 48 (REMOVING THE LOWER COVERS OF THE REAR PART OF THE FAIRING). N Remove the spark plug inspection cover, see p. N Unscrew and extract the screw (1), taking the washer and the carburettor drain pipe ring (2). N By inserting the key in the apposite hole (3) on the rear part of the fairing, unscrew and extract the screw (4) with the relative washer. N Grasp the sleeve (6) in correspondence with the hose clamp and pull it, thus removing the whole air cleaner (7). N CLEANING THE AIR FILTER Unscrew the three screws (8). N Remove the filter case cover (9) and extract the filtering element. N To clean the filtering element use clean, non-inflammable solvents or solvents with high volatility point, then let it dry thoroughly. N Apply a filter oil or a thick oil (SAE 80W90) on the whole surface of the filtering element, then squeeze it to eliminate the oil in excess. N c c The filter must be well impregnated, though not dripping. Remember: 1 mile = 1. 6 km 1 km = 0. 625 miles use and maintenance Gulliver 50 39 #(%#+). ' 4(% 42!. 3-)33)/. /), , %6%, DO NOT DISPOSE OF THE TRANSMISSION OIL IN THE ENVIRONMENT Carefully read page 37 (MAINTENANCE). To check the transmission oil level, carry out the following operations every 3000 km or every 6 months: N Drive for a few miles until the engine reaches the normal running temperature, then stop it. N Position the vehicle on the central stand. N N N N N Put a graduated container with at least 120 cm# capacity under the drain plug (1). Unscrew the filling cap (2) and the oil drain plug (1). Let all the oil flow out of the oil pan, measure the quantity and if it is less than 110 cm#, top up by adding the lacking quantity. Tighten the drain plug and provide for topping up. Tighten the filling cap. es. a Tighten the filling cap and the drain plug thoroughly and make sure that there are no oil leakag- Periodically check that there are no leakages in correspondence with the oil pan cover seal. Do not use the vehicle with insufficient lubrication or with contaminated or unsuitable lubricants, since this would accelerate the wear of the moving parts and may also cause irreparable failures. c Remember: 1 mile = 1. 6 km 1 km = 0. 625 miles 40 use and maintenance Gulliver 50 #(!. '). ' 4(% 42!. 3-)33)/. /), a In case of oil leaks or malfunctions, contact your APRILIA Official Dealer. DO NOT DISPOSE OF THE TRANSMISSION OIL IN THE ENVIRONMENT C ar e f u l l y r e a d p a g e 3 7 ( M A I N T E NANCE). To ensure the efficiency and long life of the vehicle, it is necessary to change the oil after the first 500 km and successively every 12000 km or every 2 years. To change the oil proceed as follows: Drive for a few miles until the engine reaches the normal running temperature, then stop it. N Position the vehicle on the central stand. N Put a graduated container with at least 120 cm# capacity under the drain plug (1). N Unscrew the filling cap (2) and the oil drain plug (1). [. . . ] 12 V - 3 W Low beam warning light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 V - 2W High beam warning light J - % . . . . . . . . . . . . . . . . . . 12 V - 2W Direction indicator warning light . . . . . . . . . . . . . . . . . . . . . . 12 V - 2W Mixer oil reserve warning light . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]