User manual APRILIA HABANA 125 PART1

[. . . ] - Noale (VE) 3!&%49 7!2. ). '3 The following precautionary warnings are used throughout this manual in order to convey the following messages: find aSafety warning. When youor in this symbol on the vehicle the 4%#(. )#!, The operations preceded by this symbol must be repeated also on the opposite side of the vehicle. If not expressly indicated otherwise, for the reassembly of the units repeat the disassembly operations in reverse order. The terms "right" and "left" are referred to the rider seated on the vehicle in the normal riding position. [. . . ] Switch off the direction indicators as soon as you have changed direction. Be extremely careful when you overtake other vehicles or are overtaken. In case of rain, the water cloud created by big vehicles reduces visibility; the air shift may make you lose control of the vehicle. ing light "j" comes on during the normal functioning of the engine, this means that the 2 stroke oil reserve is being used; in this case, top up the 2 stroke oil tank, see p. 25. . ). ' ). aWARNING w v If the 2 stroke oil reserve warn- carry out the checking operations indicated in the column "After running-in" of the REGULAR SERVICE INTERVALS CHART x u, see p. 46, in order to avoid hurting yourself or other people and/or damaging the vehicle. The running-in of the engine is primary to ensure its correct functioning and its correct functioning. If possible, drive on hilly roads and/or roads with many bends, so that the engine, the suspensions and the brakes undergo a more effective runningin. aWARNING x u After the first 1000 km (625 mi) carry out the checking operations indicated in the column "After running-in" of the REGULAR SERVICE INTERVALS CHART w v, see p. 44, in order to avoid hurting yourself or other people and/or damaging the vehicle. aWARNING w v After the first 500 km (312 mi) NOTE The best acceleration and speed performance of the vehicle can be obtained only after running-in. use and maintenance Habana 50/125 - Habana Custom 50/125 39 wv For the first 500 km (312 mi), keep to the following indications: N xu Keep to the following indications: N Do not open the throttle completely if the speed is low, both during and after the running-in. N N N 0-100 km (0-62 mi) During the first 100 km (62 mi), put on the brakes with caution and avoid sharp and prolonged brakings. This ensures the correct bedding-in of the friction material of the pads on the brake disc and of the shoes on the rear wheel drum. 0-300 km (0-187 mi) Do not keep the throttle grip open more than one half for long stretches. 300-500 km (187-312 mi) Do not keep the throttle grip open more than three-fourths for long stretches. Avoid driving at constant speed for long distances. After the first 1000 km (625 mi), progressively increase the speed until reaching the highest performance levels. N 0-100 km (0-62 mi) During the first 100 km (62 mi), put on the brakes with caution and avoid sharp and prolonged brakings. This ensures the correct bedding-in of the friction material of the pads on the brake disc and of the shoes on the rear wheel drum. 0-300 km (0-187 mi) Do not keep the throttle grip open more than one half for long stretches. 500-1000 km (312-625 mi) During the first 1000 km (625 mi), do not exceed the 80% of the maximum allowed speed. 34/00). ' aWARNING If possible, avoid stopping abruptly, slowing down suddenly and braking at the last moment. N N N N N Release the throttle grip (Pos. A) and gradually put on the brakes to stop the vehicle. In case of a brief stop, keep at least one brake on. 40 use and maintenance Habana 50/125 - Habana Custom 50/125 0!2+). ' aWARNING Park the vehicle on firm and flat ground, to prevent it from falling down. Neither lean the vehicle against walls, nor lay it on the ground. Make sure that the vehicle and especially its red-hot parts do not represent a danger for persons and children. Do not leave the vehicle unattended when the engine is on or the key is inserted into the ignition switch. Do not sit on the vehicle when the stand is down. N N Stop the vehicle, see p. Move the engine stop switch (1) to position "m" (for the countries where required). NOTE It is not necessary to close the fuel tap when the engine is off, since it is equipped with an automatic closing system. aCAUTION With stopped engine and ignition switch in position "n", the battery may run down. N N N aCAUTION Never leave the key in the ignition switch. [. . . ] 20W 33% of the volume, or FORK 5W 67% of the volume + 0 F. A. 20W 67% of the volume, or FORK 5W 33% of the volume + FORK 20W 67% of the volume. Bearings and other lubrication points (recommended): 0 AUTOGREASE MP or As an alternative to the recommended product, use high-quality grease for rolling bearings, working temperature range -30°C. . . . 230°C, high protection against corrosion, good resistance to water and oxidation. [. . . ]